XtremepowerUS 75117 - Winterization; Care of Electric Motor

18
MAINTENANCE
WINTERIZATION
Freeze damage is not covered by the warranty, so it's essential to take precautions if the air
temperature drops below 35° F. Follow the procedures listed below to prevent freeze damage:
Storing Pump for Winterization
• Turn off the electrical power for the pump at the house circuit breaker.
• Drain the water from the pump case by removing the two drain plugs from the case. Store these
plugs in the pump basket.
• Cover the motor to shield it from severe rain, snow, and ice.
• Avoid wrapping the motor in plastic, as it can lead to condensation and rust on the inside of the
motor.
CARE OF ELECTRIC MOTOR
• Protection from heat:
▪ Shield the motor from direct sunlight by providing shade.
▪ Ensure any enclosure used is well-ventilated to prevent overheating.
▪ Promote ample cross ventilation to keep the motor cool.
• Protection against dirt:
▪ Safeguard the motor from any foreign matter or splashing water.
▪ Avoid storing pool chemicals near the motor to prevent potential damage.
▪ Refrain from sweeping or stirring up dust near the motor while it's in operation.
▪ Remember that motor damage caused by dirt will void the motor warranty.
• Protection against moisture:
▪ Shield the motor from splashing pool water and lawn sprinklers.
▪ Keep it protected from harsh weather conditions.
▪ If the motor gets wet, allow it to dry completely before operating it again. Avoid using the
pump if it has been flooded.
▪ Note that water damage to the motor will void the motor warranty.
In mild climate areas where temporary freezing conditions may occur, it is essential to run your
filtering equipment throughout the night to prevent freezing.
Never wrap the motor with plastic or any other airtight materials. While it's acceptable to cover the
motor during a storm or for winter storage, it should never be covered while it is operating or
expected to be in operation.
When replacing the motor, ensure that the motor support is correctly positioned to adequately
support the size of the motor being installed.
CAUTION
CAUTION
NOTE