cause the electrical controls of the lift truck to operate
incorrectly.
WARNING
The acid in the electrolyte can cause injury. If the elec-
trolyte is spilled, use water to flush the area and make
the acid neutral with a solution of soda and water (1
pound of baking or commercial soda to 1 gallon of
water). Acid in the eyes must be flushed with water.
Have a doctor check the eyes.
WARNING
Batteries generate explosive fumes. Keep the vents in
the caps clean. Keep sparks or open flame away from
the battery area. Do not make sparks with the battery
connectors. Disconnect the battery when doing mainte-
nance.
WARNING
DO NOT put tools on the battery.
Check for loose or broken electrical connections and dam-
aged wires or cables. Examine the battery case for damage
and leakage. See the battery dealer in the area to repair
any damage to the battery or cables.
Keep the battery case, top cover, and battery areas clean
and painted. Use a water and soda solution to clean the
battery and the battery area (1 pound of baking or commer-
cial soda ash to 1 gallon of water). Keep the top of the bat-
tery clean, dry, and free of corrosion.
NOTE: The following electrolyte level and specific gravity
checks are not necessary for low maintenance batteries.
Check that the vent caps are clear. Check the electrolyte
level daily on a minimum of one cell and on all cells every
week. Fill to the correct level according to the battery man-
ufacturer's recommendations. Add only distilled water. Use
a hydrometer to check that the battery is not discharged
below the minimum specific gravity given by the manufac-
turer and has enough charge to complete a work period.
See Figure 15.
Charging the Battery
WARNING
The acid in the electrolyte can cause injury. Use water
to flush the area and make the acid neutral with a solu-
tion of soda and water (1 pound of baking or commer-
cial soda to 1 gallon of water). Acid in the eyes must be
flushed with water.
Maintenance
58
To Next Page
Loading...
Need help?
General
