York F2FP042 - User Manual

20 pages

Save Page as PDF

To Next Page

To Next Page

Loading...

INSTALLATION

MANUAL

CAUTION: READ ALL SAFETY GUIDES BEFORE YOU

START TO INSTALL YOUR UNIT.

SAVE THIS MANUAL

SINGLE PIECE AIR HANDLERS

HEAT PUMP MODELS

F2RP / F2FP018 THRU 060

F3RP / F3FP018 THRU 060

COOLING MODELS

F2RC / F2FC 024 THRU 036

035-14520-001 Rev. B (0803)

TABLE OF CONTENTS

GENERAL INFORMATION . . . . . . . . . . . . . . . . . . . . . . . 2

INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

REFERENCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

LIMITATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

LOCATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

HORIZONTAL DRAIN PAN INSTALLATION /

CONVERSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

DIMENSIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

DUCT CONNECTORS . . . . . . . . . . . . . . . . . . . . . . . . . . 5

AIR FILTERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

SUSPENSION KITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

COIL METERING DEVICES . . . . . . . . . . . . . . . . . . . . . . 6

REFRIGERANT LINE CONNECTION . . . . . . . . . . . . . . . 7

ELECTRIC HEATERS & OPERATING CONTROLS . . . 8

LOW VOLTAGE CONTROL CONNECTION . . . . . . . . . . 8

LINE POWER CONNECTIONS . . . . . . . . . . . . . . . . . . . . 8

BLOWER SPEED CONNECTIONS . . . . . . . . . . . . . . . . 8

DRAIN CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . 19

MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

COIL CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

CONDENSATE DRAINS . . . . . . . . . . . . . . . . . . . . . . . . 19

TROUBLESHOOTING GUIDE . . . . . . . . . . . . . . . . . . . 19

Questions and Answers

D
dmartinezAug 8, 2025
Why does my York Air Handler blower run all the time?
- D
  dandrewsAug 9, 2025
  If the blower in your York Air Handler is running continuously, here's what might be happening and how to address it: * **Thermostat Setting:** Ensure that the thermostat fan switch is set to the “AUTO” position, not “ON”. * **Blower Delay:** The blower might be in its normal OFF delay, which lasts approximately 1 minute. Wait and see if it stops. * **Connectors and Limits:** Check the installation of the 6-pin connector. Also, inspect the limit switch connection. * **Variable Speed Tab:** Look for a broken variable speed break-out tab.
T
Timothy HernandezAug 15, 2025
What to do if my York Air Handler has no heat or limited heating?
- J
  Joseph SmithAug 15, 2025
  If your York Air Handler isn't providing enough heat, or no heat at all, here are a few things to check: 1. **Airflow:** Make sure that all registers are open and that there are no obstructions restricting airflow to either the supply or return registers. 2. **Filter:** Inspect the filter and replace it if it's dirty. 3. **Blower Motor:** Check to ensure the blower motor is functioning correctly. 4. **Safety Limit:** If the safety limit has opened 4 times, the control will prevent the heating element from operating for 1 hour. Allow the control to reset.
S
sharon97Aug 20, 2025
How to troubleshoot no 2nd stage heat in York F2FP042 Air Handlers?
- M
  Melissa HernandezAug 21, 2025
  If your York Air Handler is not providing 2nd stage heat, here’s what you should check: * **Connectors and Relays:** Inspect the 6-pin connector and the connections to the panel mount relays. * **Terminal Strip Connections:** Verify that both W1 and W2 are securely connected at the terminal strip.
B
bradchapmanAug 27, 2025
What to do if my York Air Handler has no 24V?
- J
  jeffrey71Aug 27, 2025
  If your York Air Handler has no 24V, here are a few things to check: * **4-Pin Connector:** Ensure the 4-pin connector is securely in place. * **Wiring:** Inspect and secure any loose wire connections from the control to the transformer (both 24V and 230V). * **Fuse:** Replace any blown fuse located on the control board.
J
Joseph SalazarSep 2, 2025
Why does my York F2FP042 keep blowing fuses?
- R
  Rhonda DeanSep 2, 2025
  To address a blown fuse in your York Air Handler, check for low voltage shorts to C or ground from R, Y, G, W, or O.

Summary

General Information

Inspection

Reference

Limitations

Location

Horizontal Drain Pan Installation; Conversion

Dimensions

Duct Connectors

Air Filters

Suspension Kits

Coil Metering Devices

Orifice Metering Device

Orifice Installation

Refrigerant Line Connection

Electric Heaters & Operating Controls

Low Voltage Control Connection

Line Power Connections

Blower Speed Connections

Drain Connections

Maintenance

Coil Cleaning

Procedure for cleaning the heat exchanger coil with a specific solution.

Lubrication

Information regarding the permanent lubrication of blower motor bearings.

Condensate Drains

Checking condensate flow to ensure proper operation and prevent issues.

Troubleshooting Guide

Summary

General Information

Inspection

Reference

Limitations

Location

Horizontal Drain Pan Installation; Conversion

Dimensions

Duct Connectors

Air Filters

Suspension Kits

Coil Metering Devices

Orifice Metering Device

Orifice Installation

Refrigerant Line Connection

Electric Heaters & Operating Controls

Low Voltage Control Connection

Line Power Connections

Blower Speed Connections

Drain Connections

Maintenance

Coil Cleaning

Procedure for cleaning the heat exchanger coil with a specific solution.

Lubrication

Information regarding the permanent lubrication of blower motor bearings.

Condensate Drains

Checking condensate flow to ensure proper operation and prevent issues.

Troubleshooting Guide

York F2FP042 Specifications

General

Brand	York
Model	F2FP042
Category	Air Handlers
Language	English

Related product manuals

Preview: York F2RP018

York F4FP042H06T2A

York F4FP036H06T2A

York F4FP030H06T2A