Zoeller 153 Series Installation Instruction


© Copyright 2011 Zoeller Co. All rights reserved.
we do not authorize any representative or other person to assume for us any other
liability in connection with our products.
&RQWDFW0DQXIDFWXUHUDW&DQH5XQ5RDG/RXLVYLOOH.HQWXFN\$WWHQWLRQ
&XVWRPHU6HUYLFH'HSDUWPHQWWRREWDLQDQ\QHHGHGUHSDLURUUHSODFHPHQWRISDUWV
or additional information pertaining to our warranty.
MANUFACTURER EXPRESSLY DISCLAIMS LIABILITY FOR SPECIAL,
CONSEQUENTIAL OR INCIDENTAL DAMAGES OR BREACH OF EXPRESSED
OR IMPLIED WARRANTY; AND ANY IMPLIED WARRANTY OF FITNESS FOR A
PARTICULAR PURPOSE AND OF MERCHANTABILITY SHALL BE LIMITED TO
THE DURATION OF THE EXPRESSED WARRANTY.
Some states do not allow limitations on the duration of an implied warranty, so the
DERYHOLPLWDWLRQPD\QRWDSSO\WR\RX6RPHVWDWHVGRQRWDOORZWKHH[FOXVLRQRU
OLPLWDWLRQRILQFLGHQWDORUFRQVHTXHQWLDOGDPDJHVVRWKHDERYHOLPLWDWLRQRUH[FOXVLRQ
may not apply to you.
7KLVZDUUDQW\JLYHV\RXVSHFL¿FOHJDOULJKWVDQG\RXPD\DOVRKDYHRWKHUULJKWV
which vary from state to state.
Manufacturer warrants, to the purchaser and subsequent owner during the warranty
period, every new product to be free from defects in material and workmanship under
normal use and service, when properly used and maintained, for a period of three
years from the date of original manufacture. Parts that fail within the warranty period,
that inspections determine to be defective in material or workmanship, will be repaired,
replaced or remanufactured at Manufacturer's option, provided however, that by so
doing we will not be obligated to replace an entire assembly, the entire mechanism
or the complete unit. No allowance will be made for shipping charges, damages,
labor or other charges that may occur due to product failure, repair or replacement.
7KLVZDUUDQW\GRHVQRWDSSO\WRDQGWKHUHVKDOOEHQRZDUUDQW\IRUDQ\PDWHULDORU
product that has been disassembled without prior approval of Manufacturer, subjected
to misuse, misapplication, neglect, alteration, accident or act of God; that has not
been installed, operated or maintained in accordance with Manufacturer's installation
LQVWUXFWLRQVWKDWKDVEHHQH[SRVHGWRRXWVLGHVXEVWDQFHVLQFOXGLQJEXWQRWOLPLWHGWR
WKHIROORZLQJVDQGJUDYHOFHPHQWPXGWDUK\GURFDUERQVK\GURFDUERQGHULYDWLYHV
RLOJDVROLQHVROYHQWVHWFRURWKHUDEUDVLYHRUFRUURVLYHVXEVWDQFHVZDVKWRZHOV
RUIHPLQLQHVDQLWDU\SURGXFWVHWFLQDOOSXPSLQJDSSOLFDWLRQV7KHZDUUDQW\VHWRXW
LQWKHSDUDJUDSKDERYHLVLQOLHXRIDOORWKHUZDUUDQWLHVH[SUHVVHGRULPSOLHGDQG
ELECTRICAL PRECAUTIONS- Before servicing a pump, always shut off the main power breaker and then unplug the pump - making
VXUH\RXDUHZHDULQJLQVXODWHGSURWHFWLYHVROHVKRHVDQGQRWVWDQGLQJLQZDWHU8QGHUÀRRGHGFRQGLWLRQVFRQWDFW\RXUORFDOHOHFWULFFRPSDQ\RUD
TXDOL¿HGOLFHQVHGHOHFWULFLDQIRUGLVFRQQHFWLQJHOHFWULFDOVHUYLFHSULRUWRSXPSUHPRYDO
Submersible pumps contain oils which becomes pressurized and hot under operating conditions - allow 2½ hours after disconnecting before
attempting service.
If the above checklist does not uncover the problem, consult the factory - Do not attempt to service or otherwise disassemble pump. Service must be
performed by Zoeller Authorized Service Stations. Go to www.zoellerpumps.com/servicestationsWRÀQGWKH$XWKRUL]HG6HUYLFH6WDWLRQLQ\RXUDUHD
IC C C I T
A O ON T O IN TA IN A U U
1. DO read thoroughly all installation material provided with the pump.
2. DOLQVSHFWSXPSIRUDQ\YLVLEOHGDPDJHFDXVHGE\VKLSSLQJ&RQWDFW
dealer if pump appears to be damaged.
3. DO clean all debris from the sump. Be sure that the pump will have a hard,
ÀDWVXUIDFHEHQHDWKLWDO NOT install on sand, gravel or dirt.
4. DO be sure that the sump is large enough to allow proper clearance for the
OHYHOFRQWUROVZLWFKHVWRRSHUDWHSURSHUO\
5. DO Always Disconnect Pump From Power Source Before Handling.
DO always connect to a separately protected and properly grounded
circuit.
DONOTHYHUFXWVSOLFHRUGDPDJHSRZHUFRUG2QO\VSOLFHLQDZDWHUWLJKW
MXQFWLRQER[
DO NOT carry or lift pump by its power cord.
DO NOTXVHDQH[WHQVLRQFRUGZLWKDVXPSSXPS
6. DO install a check valve and a union in the discharge line.
DO NOT use a discharge pipe smaller than the pump discharge.
7. DONOTXVHDVXPSSXPSDVDWUHQFKRUH[FDYDWLRQSXPSRUIRUSXPSLQJ
sewage, gasoline, or other hazardous liquids.
8. DO test pump immediately after installation to be sure that the system is
working properly.
9. DO cover sump with an adequate sump cover.
10. DO review all applicable local and national codes and verify that the installation
conforms to each of them.
11. DOFRQVXOWPDQXIDFWXUHUIRUFODUL¿FDWLRQVRUTXHVWLRQV
12. DO
consider a two pump system with an alarm where an installation may become
overloaded or primary pump failure would result in property damages.
13. DOFRQVLGHUD'&%DFNXS6\VWHPZKHUHDVXPSRUGHZDWHULQJSXPS
LVQHFHVVDU\IRUWKHSUHYHQWLRQ RISURSHUW\GDPDJHVIURPÀRRGLQJGXH
WR$&SRZHU GLVUXSWLRQVPHFKDQLFDORUHOHFWULFDOSUREOHPVRUV\VWHP
overloading.
14. DO inspect and test system for proper operations at least every three
months.
CONDITION COMMON CAUSES
A. Pump will not start or run. &KHFNIXVHORZYROWDJHRYHUORDGRSHQRSHQRULQFRUUHFWZLULQJRSHQVZLWFKLPSHOOHURUVHDOERXQGPHFKDQLFDOO\
defective capacitor or relay when used, motor or wiring shorted. Float assembly held down. Switch defective,
damaged, or out of adjustment.
B. Motor overheats and trips overload
or blows fuse.
,QFRUUHFWYROWDJHQHJDWLYHKHDGGLVFKDUJHRSHQORZHUWKDQQRUPDOLPSHOOHURUVHDOERXQGPHFKDQLFDOO\GHIHF-
tive capacitor or relay, motor shorted.
C. Pump starts and stops too often. )ORDWWLJKWRQURGFKHFNYDOYHVWXFNRUQRQHLQVWDOOHGLQORQJGLVWDQFHOLQHRYHUORDGRSHQOHYHOVZLWFKVGHIHF-
tive, sump pit too small.
D. Pump will not shut off. 'HEULVXQGHUÀRDWDVVHPEO\ÀRDWRUÀRDWURGERXQGE\SLWVLGHVRURWKHUVZLWFKGHIHFWLYHGDPDJHGRURXWRI
adjustment.
E. Pump operates but delivers little or
no water.
&KHFNVWUDLQHUKRXVLQJGLVFKDUJHSLSH RULIFKHFNYDOYHLVXVHGYHQWKROHPXVWEHFOHDU'LVFKDUJH KHDG
H[FHHGVSXPSFDSDFLW\/RZRULQFRUUHFWYROWDJH,QFRUUHFWPRWRUURWDWLRQ&DSDFLWRUGHIHFWLYH,QFRPLQJZDWHU
containing air or causing air to enter pumping chamber.
F. Drop in head and/or capacity after
a period of use.
Increased pipe friction, clogged line or check valve. Abrasive material and adverse chemicals could possibly
GHWHULRUDWHLPSHOOHUDQGSXPSKRXVLQJ&KHFNOLQH5HPRYHEDVHDQGLQVSHFW
I

Zoeller 153 Series Specifications

General

Brand	Zoeller
Model	153 Series
Category	Water Pump
Language	English