To Next Page

To Previous Page



O IN TA ATION

WIRING DIAGRAM FOR MODELS

:'93K+]

:+93K+]

0RGHOV:':+DUHIXOO\DXWRPDWLF$ÀRDWVZLWFKLVLQFOXGHGDQG

factory wired in the pump circuit to provide automatic operation

RQFHWKHÀRDWVZLWFKLVVHFXUHGSURSHUO\WRWKHRXWOHWSLSH8VHWKH

GLDJUDPDERYHWRVHFXUHWKHÀRDWVZLWFKSURSHUO\DQGREWDLQWKH

proper tether to customize the on-off cycle to each application.

Determining Pumping Range

in Inches (1 inch - 2.5 cm)

7HWKHU/HQJWK 5 10 15 20 22

3XPSLQJ5DQJH 9 13.5 18 22 24

PD[

Use only as a guide. Due to weight of

cable, pumping range above horizontal

is not equal to pumping range below

KRUL]RQWDO5DQJHVDUHEDVHGRQWHVWLQJLQ

nonturbulent conditions.5DQJHPD\YDU\

due to water temperature and cord shape.

As tether length increases, so does the

variance of the pumping range.

PLQ

START

OTOR

WHITE

ROWN

YELLOW

LACK

SWITCH

FLOAT

LACK

WHITE

CAPACITOR

WHITE

GREEN



Note:Failure to keep within proper tether limits

may prevent reliable switch operation.

Note: &DEOHPXVW EHPRXQWHGLQ KRUL]RQWDO

position.

20 A C

6.

T A I IN IN T UCTION

FOR YOUR PROTECTION, ALWAYS

DISCONNECT PUMP FROM ITS POWER SOURCE

BEFORE HANDLING.

7RDXWRPDWLFDOO\RSHUDWHDQRQDXWRPDWLFWKUHHSKDVHSXPSD

control panel is required. Follow the instructions provided with the

panel to wire the system. For automatic three phase pumps see

automatic 3 phase wiring diagram located to the far right.

Before installing a pump, check the pump rotation to ensure that

wiring has been connected properly to power source, and that

WKHJUHHQOHDGRISRZHUFRUG6HHZLULQJGLDJUDPLVFRQQHFWHG

to a valid ground. Momentarily energize the pump, observing the

GLUHFWLRQVRINLFNEDFNGXHWRVWDUWLQJWRUTXH5RWDWLRQLVFRUUHFWLI

kick back is in the opposite direction of rotation arrow on the pump

casing. If rotation is not correct, switching of any two power leads

other than ground, should provide the proper rotation.

All three phase pumps require motor starting devices with motor

RYHUORDGSURWHFWLRQ6HH)0IRUGXSOH[LQVWDOODWLRQV3XPSV

mustEHLQVWDOOHGLQDFFRUGDQFHZLWKWKH1DWLRQDO(OHFWULFDO&RGH

and all applicable local codes and ordinances. Pumps are not to

EHLQVWDOOHGLQORFDWLRQVFODVVL¿HGDVKD]DUGRXVLQDFFRUGDQFH

ZLWK1DWLRQDO(OHFWULFDO&RGH$16,1)3$

NONAUTO ATIC

AUTO ATIC

OTOR

LACK

GREEN YELLOW

YELLOW

GREY

ROWN



IN A I IN IN T UCTION

FOR YOUR PROTECTION, ALWAYS DISCONNECT PUMP FROM ITS POWER SOURCE BEFORE HANDLING. Single phase pumps

are supplied with a 3-prong grounded plug to help protect you against the possibility of electrical shock. DO NOT UNDER ANY CIRCUMSTANCES

REMOVE THE GROUND PIN.7KHSURQJSOXJmust be inserted into a mating 3-prong grounded receptacle. If the installation does not have such

DUHFHSWDFOHLWPXVWEHFKDQJHGWRWKHSURSHUW\SHZLUHGDQGJURXQGHGLQDFFRUGDQFHZLWKWKH1DWLRQDO(OHFWULFDO&RGHDQGDOODSSOLFDEOHORFDOFRGHV

and ordinances.

“Risk of electrical shock” Do not remove power supply cord and strain relief or connect conduit directly to the pump.

,QVWDOODWLRQDQGFKHFNLQJRIHOHFWULFDOFLUFXLWVDQGKDUGZDUHVKRXOGEHSHUIRUPHGE\DTXDOL¿HGOLFHQVHGHOHFWULFLDQ

8QLWVVXSSOLHGZLWKRXWDSOXJVLQJOHDQGWKUHHSKDVHDQGVLQJOHSKDVHQRQDXWRPDWLFXQLWVZLWKDDPSSOXJPXVWKDYHDPRWRUFRQWURO

DQGOLTXLGOHYHOFRQWUROSURYLGHGDWWLPHRILQVWDOODWLRQ7KHFRQWUROGHYLFHVKRXOGKDYHVXLWDEOHYROWDJHDPSHUHIUHTXHQF\JURXQGLQJDQGKRUVHSRZHU

rating for the pump to which it is connected.

IMPORTANT NOTICE: 6RPHLQVXUDQFHSROLFLHVERWKFRPPHUFLDODQGUHVLGHQWLDOH[WHQGFRYHUDJHIRUGDPDJHVLQFXUUHGE\SURGXFWIDLOXUH<RXZLOOQHHGWR

KDYHSRVVHVVLRQRIWKHSURGXFWWRVXSSRUW\RXUFODLPLQPRVWFDVHV=RHOOHU3XPS&RZLOOH[FKDQJHWKHXQLWRUUHIXQGWKHRULJLQDOSXUFKDVHSULFHRQFHWKHFODLP

is settled with the insurer in the case where you need to retain possession of the product to support a damage claim you submit to your insurance company.

