Zoeller AquaNot Fit 508 User Manual

SECTION: 2.65.013
FM3124
0320
Supersedes
0918
TECHNICAL DATA SHEET
MODEL 508 12-VOLT BACKUP
Submersible Sump Pump System
Product information presented
here reects conditions at time
of publication. Consult factory
regarding discrepancies or
inconsistencies.
© Copyright 2020 Zoeller
®
Co. All rights reserved.
502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | zoellerpumps.com
CONTROLLER
The Aquanot
®
Fit 508 with Z Control
®
technology is a premium high
performance, self-testing internet-connected battery backup pump
system.
PUMP
• 12 volt, highly efcient, non-corrodible pump construction.
Supplied with 9' (2.7 m) leads.
• Legs allow free-standing installation
• Quick disconnect discharge
• Aluminum seal pocket and cooling plate
• Integrated check valve
CONTROLLER
The Aquanot
®
Fit DC Controller keeps the battery charged. The
controller has many built-in features such as:
• Monitors the switches,runs the pump
• Performs Self-testing diagnostics
• Communicates with the Z Control
®
Cloud; receives
commands from user through Cloud such as "Silence",
"Reset", "Test", and many conguration changes
• 7 amp
BUTTONS
• Alarm Silence/Reset - press to silence alarms. Press and hold
for three seconds to reset alarms.
• Test - Press to initiate pump test
SWITCHES
• Reliable, vertical oat switch for adjustable operation.
• High water reed sensor provides high water signal and
redundant pump run.
BATTERY CASE
The included battery case will accommodate maximum battery
dimensions of 13" (330 mm) L x 7-1/2" (191 mm) W x 9-1/2" (241
mm) H and ts all group size 27, 29 and 31 batteries. Made from
non-corrodible polyethylene. To use multiple batteries, order extra
battery case with hookup wire (P/N 007861).
FITTINGS
An integrated DC pump discharge check valve, additional thread-in
AC pump check valve, tee, and adapter are included.
• Connection fault
• Power outage/restored
• Pump activation
ALERTS
• Pump cycled
• High water
• Battery fault
• Switch fault
• Pump fault
Aquanot
®
Deep-cycle Battery (purchase separately)
P/N 10-1450 - AGM (shown)
P/N 10-0761 - Wet
Aquanot
®
Fit 508 system
Patent No. D740329
AQUANOT
®
FIT
Solid Flashing Off
System
Ready
No Faults (Green)
AC off with no
faults (Green)
--
Battery
Charged (Green)
Low Battery (Red) No AC Power
Charging (Yellow)
Bad Battery (Red)
DC pump
Pump Ran
(Yellow)
Pump Running
(Yellow)
--
Pump Fault (Red)
Float
Status
High Water (Red) Float Fault (Red) --
Z Control Connected Searching
Broadcasting
SSID or
Dormant

Zoeller AquaNot Fit 508 Specifications

General

Type	Submersible Sump Pump
Horsepower	1/3 HP
Voltage	115 V
Cord Length	10 ft
Housing Material	Cast Iron
Impeller Material	Thermoplastic
Seal Type	Mechanical
Thermal Protection	Yes
Float Switch Included	Yes
Phase	Single-Phase
Discharge Size	1-1/2" NPT
Switch Type	Vertical

Summary

Pump System Overview

Controller Features

Details the Aquanot Fit DC Controller, its self-testing diagnostics, cloud communication, and operational monitoring.

Pump Specifications

Highlights the 12-volt, non-corrodible pump construction, leads, installation features, and integrated components.

Alerts and Buttons

Lists system alerts like 'High water' and 'Connection fault', and button functions for alarm silence, reset, and pump test.

Switches and Battery Case

Describes the vertical float switch, high water reed sensor, and the polyethylene battery case dimensions.

System Fittings

Details included fittings such as integrated DC pump discharge check valve and AC pump check valve.

Performance and Specifications

Total Dynamic Head Flow

Provides a table detailing flow rate in gallons and liters per minute at various head levels in feet and meters.

Pump Performance Curve

Visual representation of the Model 508 pump's performance, showing flow rate against total dynamic head.

Warranty and Battery Life

Covers the 3-year warranty for the system and battery, and estimates battery life during continuous pump operation.

Performance Data and Battery Options

Details performance based on a fully charged 12-volt battery and lists recommended deep-cycle battery sizes and types.

Installation Caution

Advises that all electrical work should be performed by a qualified electrician following safety codes.