ABS 100 - Commissioning and Maintenance; Pre-Operation Checks; Routine Maintenance Recommendations

10 Installation and Operating Instructions
ABS lifting station Piranhamat
5 Commissioning
m
The safety hints in the previous sections must be observed!
Before commissioning the unit should be checked and a functional test carried out. Particular attention should
be paid to the following:
Have the electrical connections been carried out in accordance with regulations?
Is the tank cover pushed fully home? (unit should only be operated with the cover in the fully home position).
Is the WC discharge being pumped away quickly?
Is the run-on time suitable? (a slurping noise occurs).
6 Maintenance
c
Before commencing any maintenance work the unit should be completely disconnected from the
mains by a qualied person and care should be taken that it cannot be inadvertently switched back on.
NOTE The maintenance hints given here are not designed for “do-it-yourself” repairs as
specialtechnicalknowledgeisrequired.
NOTE TheABSwarrantyconditionsareonlyvalidprovidedthatanyrepairworkhasbeen
carriedoutinABSapprovedworkshopandwhereoriginalABSsparepartshave
been used.
6.1 Maintenance of the Piranhamat 100/120 lifting unit
We recommend that the lifting unit be inspected visually every month and its functioning checked
In addition we recommend that a Maintenance Contract be concluded with a qualied specialist company.
USER TIP Switching the power supply to the unit OFF and ON will operate the unit manually.
Thismayallowcertainblockagestobeclearedwithoutdismantlingtheunit
6.2 General maintenance hints
ABS lifting units are reliable quality products each being subjected to careful nal inspection. Lubricated-for-
life ball bearings together with monitoring devices ensure optimum reliability, provided that the unit has been
connected and operated in accordance with the operating instructions.
NOTE The ABS service organisation would be pleased to advise you on any applications
you may have and to assist you in solving your pumping problems.
NOTE Amaintenancecontractwithourworksservicedepartmentwillguaranteeyouthe
best technical service under all circumstances.
6.3 Steps to be taken should a fault occur
ATTENTION Water sources which drain into the Piranhamat 100/120 should not be used should a
fault occur.
-
-
-
-
-
-