Alto-Shaam 6-10ML - Default Chapter; Table of Contents

1.0 INSTALLATION
1.1 Receiving & Transportation . . . . . . .1
1.2 Basic Installation Site Requirements . . .1
1.3 Ventilation Requirements . . . . . . . . .2
1.4 Positioning On Site . . . . . . . . . . . . .2
1.5 Installation Codes & Standards . . . .2
1.6 Installation Requirements . . . . . . . .3
1.7 Air Supply Requirements . . . . . . . . .4
1.8 Assembly Requirements . . . . . . . . . .4
1.8.1 Exhaust Gas Flue Diverter . . . .4
1.8.2 Sound Absorber . . . . . . . . . . . .4
1.8.3 Hand Shower Holder . . . . . . . .4
1.8.4 Drip Tray . . . . . . . . . . . . . . . . .4
1.8.5 Roll-In Cart (TROLLEY) Guide Rails . . . .5
1.9 Electrical Connection . . . . . . . . . . . .5
1.10 Water Supply . . . . . . . . . . . . . . . . . .6
1.11 Water Drainage . . . . . . . . . . . . . . . .6
1.12 Gas Connection Requirements . . . . .7
1.13 Gas Type and Pressure . . . . . . . . . . .7
1.14 Gas Connection . . . . . . . . . . . . . . . .7
1.15 Leak Testing . . . . . . . . . . . . . . . . . .8
1.16 Fuel Interlock System . . . . . . . . . . .8
1.17 Gas Exhaust . . . . . . . . . . . . . . . . . . .8
1.18 Gas Pressure Chart . . . . . . . . . . . . .9
1.19 Gas Flame Patterns . . . . . . . . . . . . .9
1.20 Burner Pilot Adjustment . . . . . . . .10
1.20.1 Checking Pressure . . . . . . . . .10
1.20.2 Adjust Pilot Burner . . . . . . . .10
1.20.3 Manifold Pressure Adjustment . . .10
1.20.4 Ignition & Burner Check . . . . .10
1.20.5 Verify Sequence of Operation . . . .10
1.21 Sequence of Operation . . . . . . . . . .11
1.22 Stacking Combitherm Connections .12
1.23 Post Installation Check List . . . . . .13
1.24 Emergency Operation . . . . . . . . . . .14
2.0 CONTROL PANEL IDENTIFICATION . .15-16
2.1 S-Control Panel Identification . . . .17
2.2 Safety Precautions . . . . . . . . . . . . .18
2.3 Preventive Maintenance . . . . . . . . .19
2.4 Routine Cleaning Requirements . . .19
2.5 Daily Oven Cleaning
2.5.1 Cleaning Instructions . . . . . . . .20
2.5.2 Automatic Cleaning Program . . .21
2.6 Monthly Cleaning
2.5.1 Water Intake Filter Cleaning . . . .22
2.6.2 Drain Pipe Cleaning . . . . . . . . . . .22
2.6.3 Flue Outlet Cleaning . . . . . . . . . .22
2.6.4 Fan Cleaning . . . . . . . . . . . . . . . . .23
2.7 Roll-In Cart/Food Trolley Cleaning . .24
2.8 Daily Gasket Cleaning . . . . . . . . . .24
3.0 SERVICE SECTION
3.1 Combitherm Service Record . . . . . .25
3.2 Combitherm Gas
3.2.1 Exterior Component Identification . .26
3.2.2 Operating Schematic . . . . . . . . . .26
3.2.3 Plumbing System . . . . . . . . . . . .26
3.3 Service Views — LEFT-SIDE PANEL
Models 6•10, 7•14, 10•10, 10•20, 12•18 . . .27
Control, Bypass, Water . . . . . . . . . . . . . . .28
Optional Grease Collection System . . . .29
3.4 Troubleshooting . . . . . . . . . . . . . . . . . . . . .30-31
Control Reset . . . . . . . . . . . . . . . . . . . . . . . . . .31
3.6 Combitherm Gas Parts List . . . . . . . . . . . .32-35
S-Control Parts List . . . . . . . . . . . . . . . . . . . . .36
Wiring Diagrams . . . . . . . . . . . . . . . . . . . .37-40
Transportation & Damage Claims . . . .41
Limited Warranty . . . . . . . . . . . . . . . .41
TABLE OF CONTENTS
Gas