Argo Frontier 650 8x8 2021 - 20;20 Service Chart

44
SECTION 7
MAINTENANCE INFORMATION
20/20 SERVICE CHART
20-POINT INSPECTION AFTER 20 HOURS OF OPERATION
√ Changeengineoilandlter
√ Inspectairlter
√ Changetransmissionoil
√ Inspectandadjustchaintensioners
√ Inspectsteeringandstoppingbrakeoperation
√ ChecktightnessofallbearingandsprocketCClips
√ Greaseinner,outer&outputshaftbearings
√ Lubricatedrivechains,inspectandadjustidlerchains
√ Inspectandcleanairintake
√ Inspectelectricalsystem
√ Inspectlowerbodyandskidplate
√ Adjustandsettirepressures
√ Cleanbatteryposts/topofelectrolyte/checkingcharging
system operation
√ Checkengineidlespeed&topnoloadRPM,
adjust as required
√ Adjustparkingbrakecable
√ Inspectfuelsystemandlter
√ InspectCVT’s&belt.Adjustsecondaryclutchasre-
quired
√ Re-torqueaxlebearingandextensionbolts
√ OperationalcheckofallArgoAccessories
100/12 SERVICE CHART
100 HOURS OR ONCE-A-YEAR SERVICE
√ Change engine oil and lter
√ Inspect air lter
√ Change transmission oil
√ Inspect and adjust chain tensioners
√ Inspect steering and stopping brake operation
√ Check tightness of all bearing and sprocket C Clips
√ Grease inner, outer & output sha bearings
√ Lubricate drive chains, inspect and adjust idler
chains
√ Inspect and clean air intake
√ Inspect electrical system
√ Inspect lower body and skid plate
√ Adjust and set tire pressures
√ Clean battery posts/top of electrolyte/checking
charging system operation
√ Check engine idle speed & top no load RPM, adjust
as required
√ Adjust parking brake cable
√ Inspect fuel system and lter
√ InspectCVT’s&belt.Adjustsecondaryclutchas
required
√ Re-torqueaxlebearingandextensionbolts
√ OperationalcheckofallArgoAccessories
√ Changeprimaryairlter
√ Inspectsecondaryairlter
√ Cleanpre-lterscreen(aircooledmodels)
√ Degrease/cleandrivechainsandre-lubricate
√ Inspectallbearingsforwear
√ Inspectlowerbody/skidplatefordamage
√ Inspectdrainplugseal
√ De-greaseandpowerwashvehicle
√ Replacefuellter
√ Replacesparkplugs
√ Inspectchainsliderblocks
√ Cleanandinspectsparkarrester
√ Inspectsprocketsforwear
√ Checkandadjustfanbeltifnecessary
7.5 20/20 & 100/20 SERVICE