Bioquell ProteQ - 1 Safety

BIOQUELL PROTEQ USER MANUAL -EN
TD092-O&M-001
REVISION 5 DRAFT
Page 4 of 58
14.1.2 Cleaning .............................................................................................. 37
14.1.3 Hydrogen Peroxide Liquid ....................................................................... 38
14.2 Scheduled Maintenance ................................................................... 38
15 TROUBLE SHOOTING ......................................................................... 39
15.1 Software Cycle Interlocks ................................................................ 39
15.2 Warnings & Alarms ......................................................................... 40
15.3 Fault Finding .................................................................................. 47
16 SPECIFICATION ................................................................................. 48
17 HAND HELD LOW LEVEL HYDROGEN PEROXIDE SENSOR ................... 50
18 DISTANCE MEASUREMENT DEVICE (OPTIONAL) ................................ 51
19 PARTS LIST ....................................................................................... 52
19.1 Consumables ................................................................................. 52
19.2 Replacement Parts .......................................................................... 52
20 SCREEN NAVIGATION ........................................................................ 53
21 DECLARATION OF CONFORMITY ........................................................ 55
22 DEFAULT PASSWORDS ...................................................................... 56
1 SAFETY
Safety instructions that must be observed when operating the Bioquell ProteQ
hydrogen peroxide system or handling the hydrogen peroxide bottles are listed
below.
Danger and Warning signs are used where there is potential hazard to
personnel.
The mandatory symbol is used to describe other safety precautions that
must be followed before operating the equipment.
HANDLING HYDROGEN PEROXIDE
Always wear gloves, long sleeves and eye protection when handling
Hydrogen Peroxide.
Exposure to HYDROGEN PEROXIDE LIQUID can cause burns and
blistering to the skin and tissue damage to the eyes. HYDROGEN
PEROXIDE VAPOUR can cause irritation to eyes, nose, throat, lungs and
skin, breathing difficulties and coughing.
IN ALL CASES SEEK MEDICAL ADVICE.
ACTION TO BE TAKEN ON EXPOSURE TO HYDROGEN PEROXIDE
EYES
Irrigate with sterile water for at least 10 minutes.
LUNGS
Remove casualty immediately to fresh air, rest and keep warm.
SKIN
Drench with water, remove clothing.
MOUTH
Rinse thoroughly with water and give plenty to drink.
SAFETY OBSERVANCE IS ESSENTIAL WHEN USING THIS EQUIPMENT.
READ THIS SECTION CAREFULLY BEFORE USING THE EQUIPMENT.
Only personnel who have been trained by Bioquell or their agents on the
safe use of the ProteQ should operate it.