Buhler 435 - Page 213

5-18
435/485/535
Section 5 - Troubleshooting
Fault Codes
Fault
Codes
Warning
Lamp
Cause Action
F537
B Fuel Supply Pump Inlet Pressure Low
- warning level
Check Fuel Level/Check Fuel Filter/
Contact Buhler Versatile Inc (BVI) Service Center
F538 B Turbocharger #1 Speed High
- warning level
Contact Buhler Versatile Inc (BVI) Service Center
F539 - Engine Hot Shutdown Contact Buhler Versatile Inc (BVI) Service Center
F540
B Engine Shutdown Commanded by J1939 Contact Buhler Versatile Inc (BVI) Service Center
F541
B Ambient Air Pressure Sensor Circuit
- data incorrect
Contact Buhler Versatile Inc (BVI) Service Center
F542
B Ambient Air Pressure Sensor Circuit
– shorted high
Contact Buhler Versatile Inc (BVI) Service Center
F543
B Ambient Air Pressure Sensor Circuit
– shorted low
Contact Buhler Versatile Inc (BVI) Service Center
F544
B Sensor Supply Voltage #2 Circuit
- shorted high
Contact Buhler Versatile Inc (BVI) Service Center
F545
B Sensor Supply Voltage #2 Circuit
- shorted low
Contact Buhler Versatile Inc (BVI) Service Center
F546
B & E Engine Coolant Level Sensor Circuit
- data incorrect
Contact Buhler Versatile Inc (BVI) Service Center
F547
B Power Lost without Ignition Off Contact Buhler Versatile Inc (BVI) Service Center
F548
C Engine Control Module – Internal failure Contact Buhler Versatile Inc (BVI) Service Center
F549
B Engine Control Module – data lost Contact Buhler Versatile Inc (BVI) Service Center
F550 B Engine Control Module
- Warning Software error
Contact Buhler Versatile Inc (BVI) Service Center
F551
- Fuel Shutoff Valve Circuit - shorted high Contact Buhler Versatile Inc (BVI) Service Center
F552
- Fuel Shutoff Valve Circuit - shorted low Contact Buhler Versatile Inc (BVI) Service Center
F553 C Fuel Shutoff Valve - stuck open Contact Buhler Versatile Inc (BVI) Service Center
F554
B Fueling Actuator #1 Circuit - open circuit Contact Buhler Versatile Inc (BVI) Service Center
F555 B Fueling Actuator #1 Circuit
- grounded circuit
Contact Buhler Versatile Inc (BVI) Service Center
F556
B Timing Actuator #1 Circuit - open circuit Contact Buhler Versatile Inc (BVI) Service Center
F557
B Timing Actuator #1 Circuit
- grounded circuit
Contact Buhler Versatile Inc (BVI) Service Center
F558 - SAE J1939 datalink - cannot transmit Contact Buhler Versatile Inc (BVI) Service Center
F559 B SAE J1939 Multiplexing PGN
Timeout Error
Contact Buhler Versatile Inc (BVI) Service Center
F560
B SAE J1939 Multiplexing Configuration
Error
Contact Buhler Versatile Inc (BVI) Service Center
F561
B Fan Clutch Circuit - shorted low Contact Buhler Versatile Inc (BVI) Service Center
F562
B Injector Solenoid Valve Cylinder #1 Circuit
– grounded circuit
Contact Buhler Versatile Inc (BVI) Service Center
F563
B Injector Solenoid Valve Cylinder #2 Circuit
– grounded circuit
Contact Buhler Versatile Inc (BVI) Service Center
F564
B Injector Solenoid Valve Cylinder #3 Circuit
– grounded circuit
Contact Buhler Versatile Inc (BVI) Service Center