Cameron NUFLO Scanner 2000 microEFM - Installation Procedure-Remote Mount to Orifice Meter or Cone Meter


Scanner
®
2000 microEFM Section 2
&$87,21 %HIRUHVWDUWLQJWKHV\VWHPUHPRYHWKHFDSVDQGDGGZDWHURUDQWLIUHH]HLIQHFHVVDU\WR
FRPSOHWHO\¿OOWKHSRWVDQGFROGOHJV$LUWUDSSHGLQWKHOLQHVZLOOSURGXFHHUURUVLQGLI-
ferential pressure measurements.
!
 :$51,1*(;3/26,215,6.+RXVLQJWHPSHUDWXUHPXVWQRWH[FHHG&)([FHVVLYH
WHPSHUDWXUHVZKLFKFRXOGUHVXOWIURPDPELHQWFRQGLWLRQVFRPELQHGZLWKUDGLDWHGDQGFRQGXF-
WLYHKHDWIURPWKHSURFHVVFRXOGFDXVHWKHLQWHUQDOOLWKLXPEDWWHU\WRLJQLWHRUH[SORGH
,QVWDOODWLRQ3URFHGXUH²5HPRWH0RXQWWR2UL¿FH0HWHURU&RQH0HWHU
$6FDQQHUFDQEHPRXQWHGUHPRWHO\DQGFRQQHFWHGWRDQRUL¿FHPHWHURUFRQHPHWHUZLWKWXELQJIRU
VWHDPPHDVXUHPHQW7KHVHWXSRIWKHPHWHUUXQDQGSOXPELQJFRQ¿JXUDWLRQVFDQYDU\ZLGHO\GHSHQGLQJ
XSRQWKHFKDOOHQJHVH[LVWLQJRQORFDWLRQ
3/4 in. conduit connection for
input/output & communications
Cold legs connect to manifold
(slope to eliminate air trap)
Condensate pot (pipe tee
with blowdown valve attached)
Long cold legs protect the
sensor from extreme process
temperatures
Hot legs, insulated to within 1 ft of condensate pot
(1/2 in. diameter recommended)
MVT vent (use for
for filling cold legs)
Horizontal pole mount provides
clearance for block manifold
Figure 2.9—Remote-mount steam run installation (shown here with a cone meter). The remote-mount method
FDQEHXVHGZLWKDQRUL¿FHPHWHUDVZHOO