Carel heaterSteam UR006 - Technical Features; Steam Duct Pipe Models; Models of Steam Nozzles with Concentrated Jet

62
ENG
“heaterSteam” +0300075EN - rel. 1.2 - 29.09.2015
12.2 Technical features
model
UR002 UR004 UR006 UR010 UR013 UR020 UR027 UR040 UR053 UR060 UR080
Number of heaters 11333666699
steam
Connection Ø mm (in) 30 (1.2) 40 (1.6) 2 x 40 (2x1.6)
delivery pressure limits Pa (PSI) 0…1500 (0...0,218) 0...2000 (0...0.290)
supply water
connection 3/4” G
temperature limits °C (°F) 1...40 (33.8...104)
pressure limits (MPa) 0.1...0.8 (1...8 bar)
hardness limits (°fH) ≤ 40
instant  ow rate (l/min) 1.1 1.1 1.1 1.1 1.1 4 4 4 10 10 10
drain water
Connection Ø mm (in) 40 (1.6) 50 (2)
typical temperature °C (°F) ≤100
instant  ow rate (l/min) 5 (50 Hz) - 9 (60 Hz) 17.5 (50 Hz) - 24.3 (60 Hz)
drain tempering instant  ow rate (l/min)* 23 (60Hz) 54,3 (60Hz)
* where needed
environmental conditions
room operating temperature °C (°F) 1...40 (33.9...104)
room operating humidity (% rH) 10...60
storage temperature °C (°F) -10...70 (33.8...158)
storage humidity (% rH) 5…95
protection rating IP20
system
type URH-URS
voltage / auxiliary frequency (V / Hz) 24 / 50/60
maximum auxiliary power (VA) 90
probe inputs (general characteristics)
selectable input signal: 0…1 Vdc, 0…10 Vdc, 2…10 Vdc, 0…20 mA, 4…20 mA
input impedance: 60 k with signals: 0…1 Vdc, 0…10 Vdc, 2…10 Vdc
50  with signals: 0…20 mA, 4…20 mA
power supply for active probes (general features)
24 Vdc (24 Vac recti ed), Imax= 250 mA
12 Vdc 5%, Imax= 50 mA
alarm relay outputs (general features)
250 V 8 A (2 A)
type of micro-switching action 1C
remote enabling input (general characteristics) dry contact; max resistance 50 ; Vmax=24 Vdc; Imax=5 mA
serial communication two-lead RS485
Tab. 12.b
12.3 Steam duct pipe models
humidi er model: UR002 UR004 UR006 UR010 UR013 UR020 UR027 UR040 UR053 UR060 UR080
ø of steam outlet mm (in): 30 (1.2") 40 (1.6") 2x40 (1.6")
maximum capacity kg/h
(lb/h):
"2 (4.4)” “4 (8.8)” “6 (13.2)” “10 (22)” “13 (28.6)” “20 (44)” “27 (59.5)” “40 (88)” “53 (116.8)” “60 (132.2)” “80 (176.36)”
1312365AXX (SHOSE00030) √√√ √ √
1312367AXX (SHOSE00040) √√√ √ √ √
Tab. 12.c
12.4 Models of steam nozzles with
concentrated jet
humidi er model: UR002 UR004 UR006 UR010 UR013 UR020 UR027 UR040 UR053 UR060 UR080
ø of steam outlet mm (in): 30 (1.2”) 40 (1.6”) 2x40 (1.6”)
maximum capacity kg/h (lb/h):
2
(4.4)
4
(8.8)
6
(13.2)
10
(22)
13
(28.6)
20
(44)
27
(59.5)
40
(88)
53
(116.8)
60
(132.2)
80
(176.36)
“inlet diameter
nozzle ø mm (in)”
maximum capacity
nozzle kg/h (lb/h)
code
30 (1.2”) 18 (39.7) SDPOEM0022 1 11111(2)*
30 (1.6”) “18 (39.7)
with hole of 30 (1.6””)” SDPOEM0000 1 1 1111(2)* (4)* (4)* (4)*
Tab. 12.d
*: use Y-type CAREL kit code UEKY000000, inlet 40mm (1.6”)
and 2 outlets 30mm (1.2”)
**: use Y-type CAREL kit code UEKY40Y400, inlet 40mm (1.6”)
and 2 outlets 40mm (1.6”)