SD Carel USA
3
Table of Contents
1. General Installation Rules......................................................................................................................... 5
2. Mount Steam Humidifier.......................................................................................................................... 6
2.1. Position of Steam Outlets.................................................................................................................. 7
2.2. Mounting The Humidifier................................................................................................................. 7
3. Connect Plumbing..................................................................................................................................... 8
3.1. Connect Water Feed.......................................................................................................................... 8
3.2. Connect Water Drain ........................................................................................................................ 8
4. Connect Power Wiring.............................................................................................................................. 9
5. Connect Control Wiring.......................................................................................................................... 10
5.1. Controls Placement......................................................................................................................... 10
5.2. Controls Wiring .............................................................................................................................. 10
6. Install Steam Distributor Pipes ............................................................................................................... 12
7. Install Steam Hoses................................................................................................................................. 13
8. Install Room Distribution Unit ............................................................................................................... 14
9. Start up and Check out of the SD 2000 Humidifier................................................................................ 16
10. Operating The SD 2000 Humidifier Controller.................................................................................. 17
10.1. Available Controller Types......................................................................................................... 17
10.2. Display Sequence........................................................................................................................ 19
11. Maintaining Your SD 2000 Humidifier.............................................................................................. 21
11.1. Optimizing Cylinder Life on the SD 2000 Electrode Steam Humidifier.................................... 23
12. Trouble Shooting ................................................................................................................................ 24
13. Replacement Parts............................................................................................................................... 30
14. Technical Specifications..................................................................................................................... 38
14.1. ASWH / ASDH – ASDH / ASDC Wall – Duct Temperature/Humidity Sensors ...................... 39
14.2. HC-101 and HC-201 Wall and Duct Humidistats ...................................................................... 40
14.3. PC-301 Air Proving Switch........................................................................................................ 41
WARNING: Your humidifier requires water to operate. Do NOT mount it above materials or
machinery that could be damaged if a leak occurs. Carel assumes no responsibility for
consequential or inconsequential damage as a result of any leaks.
To Next Page
Loading...
Need help?
General
