vi
T-305
TABLE OF CONTENTS -- Continued
PARAGRAPH NUMBER Page
6.21 REFRIGERATION CONTROLLER 74......................................................
6.21.1 Handling Controller 74................................................................
6.21.2 Controller Trouble-Shooting 74.........................................................
6.21.3 Controller Programming Procedure 75..................................................
6.21.4 Removing and Installing the Controller 75...............................................
6.21.5 Battery Replacement 75..............................................................
6.22 TEMPERATURE SENSOR SERVICE 75...................................................
6.22.1 Sensor Checkout Procedure 75........................................................
6.22.2 Sensor Replacement 76..............................................................
6.22.3 Sensor Re-Installation 77.............................................................
6.23 MAINTENANCE OF PAINTED SURFACES 77..............................................
6.24 COMPOSITE CONTROL BOX REPAIRS 77................................................
6.24.1 Introduction 77......................................................................
6.24.2 Cracks 78...........................................................................
6.24.3 Chips And Holes 78..................................................................
6.24.4 Inserts 78...........................................................................
6.24.5 Door Hinge Inserts 78................................................................
6.25 COMMUNICATIONS INTERFACE MODULE INSTALLATION 81..............................
6.26 POWER FACTOR CORRECTOR CAPACITORS (PFC) 81....................................
PART TWO -- CONTROLLED ATMOSPHERE SYSTEM 87...............................
INTRODUCTION 87..............................................................................
7.1 INTRODUCTION 87.....................................................................
DESCRIPTION 89...............................................................................
8.1 GENERAL DESCRIPTION 89...............................................................
8.1.1 CA Equipment Location -- front Section 89...............................................
8.1.2 Calibration, Gas Charge and Pressurization/Gage Ports 89................................
8.1.3 CA Components in the Refrigeration Evaporator Section 90...............................
8.1.4 Control Box 92......................................................................
8.1.5 CA Components in the Refrigeration Condenser Section 93................................
8.1.6 Container Rear Door Section 94.......................................................
8.2 CONTROLLED ATMOSPHERE SYSTEM DATA 95............................................
8.3 ELECTRICAL DATA 95.....................................................................
8.4 CONTROLLED ATMOSPHERE (CA) FLOW CIRCUIT 96.......................................
8.5 FRESH AIR MAKEUP VENT 98.............................................................
8.6 SAFETY AND PROTECTIVE DEVICES 98....................................................
MICROPROCESSOR 99..........................................................................
9.1 CONTROLLED ATMOSPHERE CONTROLLER MODULE 99...................................
9.1.1 Brief Description 99..................................................................
9.1.2 CA Controller Programming (Memory) Card 100...........................................
9.1.3 General Layout of the CA Controller Section 100..........................................
9.1.4 CA Controller Function and Data Codes 102..............................................
9.1.5 Configuration Software (Configuration Variables) 104......................................
9.1.6 CA Controller Alarms 104..............................................................
9.1.7 Controller CA Control 106..............................................................
To Next Page
Loading...
