Carrier 69NT40-489-100 Series - Page 21

vii T-305
TABLE OF CONTENTS -- Continued
PARAGRAPH NUMBER Page
9.2 CA PRE-TRIP DIAGNOSTICS 107.........................................................
9.2.1 Pre-Trip 107..........................................................................
9.2.2 Pre-Trip Mode 109....................................................................
OPERATION 111.................................................................................
10.1 CONTROLLED ATMOSPHERE (CA) PRE-TRIP INSPECTION (Before Starting) 111...............
10.2 CONTROLLED ATMOSPHERE (CA) STARTING AND STOPPING INSTRUCTIONS 111...........
10.3 START--UP INSPECTION 112...............................................................
10.4 PRE--TRIP 112............................................................................
10.5 CONTROLLED ATMOSPHERE SET POINT SELECTION 113..............................
10.6 CONTROLLED ATMOSPHERE SYSTEM OPERATION 113................................
10.7 CONTROLLED ATMOSPHERE (CA) SYSTEM CONTAINER VENTING PROCEDURE 113.........
TROUBLESHOOTING 115.........................................................................
11.1 CONTROLLED ATMOSPHERE (CA) SYSTEM WILL NOT START 115...........................
11.2 CONTROLLED ATMOSPHERE (CA) SYSTEM MALFUNCTION 115.............................
SERVICE 117....................................................................................
12.1 MAINTENANCE SCHEDULE 117...........................................................
12.2 AIR COMPRESSOR 118..................................................................
12.3 AIR COMPRESSOR SERVICE (P/N 18--00052) 118..........................................
12.4 AIR COMPRESSOR ASSEMBLY (P/N 18--00052) 121........................................
12.5 AIR COMPRESSOR SERVICE (P/N 18--00099) 122..........................................
12.6 MEMBRANE AIR FILTER 127..............................................................
12.7 AIR INTAKE FILTER 127..................................................................
12.8 AIR SAMPLE FILTER 128.................................................................
12.9 OXYGEN SENSOR 128...................................................................
12.10 CARBON DIOXIDE SENSOR 128..........................................................
12.11 NITROGEN MEMBRANE SEPARATOR 129.................................................
12.12 CONTAINER CURTAIN 131................................................................
12.13 SOLENOID VALVE 132...................................................................
12.14 CONTROLLED ATMOSPHERE (CA) CONTROLLER MODULE 132............................
12.14.1 Programming Procedure 133..........................................................
12.14.2 Troubleshooting 133..................................................................
PART THREE -- ELECTRICAL WIRING SCHEMATICS AND DIAGRAMS 135............................
13.1 INTRODUCTION 135.....................................................................
14.1 INTRODUCTION 141.....................................................................