OWNER MANUA L
EVOLUTION
Read carefully all the safety statements before attempting any procedure.
EVOLUTION
PAG E 54
OWNER MANUA L
Read carefully all the safety statements before attempting any procedure.
1
2
VEHICLE TRANSPORTATION AND TOWING
RETURNING THE VEHICLE TO SERVICE FROM STORAGE
1. Fully charge the battery.
2. Set the Forward /Reverse control (DNR) to N.
3. Adjust the pressure in each tire to the recommended tire pressure.
4. Have a trained technician lubricate the vehicle.
5. Do a daily pre-operation safety checklist.
6. Do a vehicle performance inspection.
WARNING
> DO NOT RIDE ON OR ALLOW OTHER PEOPLE ON A VEHICLE BEING TRANSPORTED ON A
TRAILER OR BEING TOWED WIT H ANOTHER VEHICLE.
> DO NOT CARRY PASSENGERS ON GOLF CART WHILE TOWING THE VEHICLE.
> APPLY BRAKE TO LIMIT SPEED WHEN COMMIT SHARP TURNS.
> APPLY BRAKE TO LIMIT SPEED WHEN TOW THE GOLF CART ON UNEVEN TERRAIN.
> TURN ON THE HAZARD LIGHTS IF VEHICLE WAS CONFIGURED WITH .
> SECURE THE SEATS/WINDSHIELD/OTHER LOOSE ITEMS BEFORE TOWING GOLF CART.
> DO NOT TOW MULTIPLE GOLF CARTS IN SERIES FORMATION .
> DO NOT TOW THE GOLF CART ON HIGHWAY ROADS .
> ABORT TOWING WHEN ABNORMAL PHENOMENONS BEING DETECTED.
> ABORT TOWING WHEN ABNORMAL PHENOMENONS BEING DETECTED.
The following steps can help you to tow an EVOLUTION golf cart
safely without any damage.
Turn off key switch.
Keep the Forward/Reverse switch in a neutral position.
If you need to tow the golf cart for long distance ,remove the battery connections from battery
pack terminals. This is done to ensure that the Rear axle /Motor/Controller/Batteries do not get
damaged during the towing process
Move the golf cart at a slower speed (Optimally Between 5-15MPH )or the same speed that you
would generally move it if it has power. Exceeding the speed limit can over-spin the motor and
ruin it.
Pulling your golf cart faster than designed to go can over-spin the motor. Possible slinging the
internal parts into pieces and ruining the motor.
Unlock the parking brakes . If you have a EM brake on your golf cart motor, make sure unlock
it mechanically before towing the golf cart.
VEHICLE MAINTE NANCE VEHICLE MAINTENANCE
JOBS TO BE DONE PRIOR TO THE STORAGE
>Put golf cart under shelter, keep the golf cart in dry and ventilated space.Optimal temperature
14°F to 95°F (-10°C to 35°C) . Maximum storage temperature should not be higher than 122 °F
(50°C).
>Turn the key switch to the OFF position, remove the key and leave the forward/reverse switch
in the NEUTRAL position during storage.
>Power down all accessories.
>Clean the battery packs, tops and terminals using a battery acid neutralizer (1 cup baking
soda per 1 gallon water).Check, clean and treat battery terminal connections with a battery
terminal protector spray.
>If your vehicle is equipped with a Single Point Watering System(for golf carts with lead-acid
battery), place the fill tube on top of the battery. This allows any water in the tube to drain back
into the batteries.
>Disconnect batteries per ensuring that the cables do not come into contact with a terminal
(Disconnect the 48V Main power outlet cables from battery pack ,insulate the cable ) .
>Connect Battery cables back to system, charge the battery to full state every 1-3 months to
keep battery alive without damages caused by over-discharging.
>Perform all semi-Annual Lubrications .
>Thoroughly clean the front and rear body ,seats ,battery compartment and underside of the
vehicle. >DO NOT engage the park brakes , but secure the golf cart from rolling. Chock the
wheels with wheel stopper or something similar .
>Check Tire pressure and infate the tires to standard pressure level as values presented on
tires.
>Perform all semi-Annual Lubrications .
>Thoroughly clean the front and rear body ,seats ,battery compartment and underside of the
vehicle.
>DO NOT engage the park brakes , but secure the golf cart from rolling. Chock the wheels with
wheel stopper or something similar .
PAG E 53
To Next Page
Loading...
General