Ezgo 2Five User Manual

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
MAINTENANCE
Owner’s Guide
111
Hydrometer
A hydrometer is used to test the state of charge of a battery cell.
This is performed by measuring the density of the electrolyte,
which is accomplished by measuring the specific gravity of the
electrolyte. The greater the concentration of sulfuric acid, the
more dense the electrolyte becomes. The higher the density,
the higher the state of charge.
Specific gravity is the measurement of a liquid that is compared to a baseline. The baseline is water which is
assigned a base number of 1.000. The concentration of sulfuric acid to water in a new golf car battery is
1.280 which means that the electrolyte weighs 1.280 times the weight of the same volume of water. A fully
charged battery will test at 1.275 - 1.280 while a discharged battery will read in the 1.140 range.
Float
Bulb
Cylinder
Thermometer
Add to Float
Reading
Subtract
from Float
Reading
Weight
To prevent battery explosion, never insert a metal
thermometer into a battery. Use a hydrometer
with a built in thermometer that is designed for
testing batteries.

Ezgo 2Five Specifications

General

Seating Capacity	4
Drive Train	Rear-wheel drive
Category	Golf Cars
Power Source	Electric
Lights	LED headlights, taillights, and brake lights
Motor	AC induction motor
Brakes	Hydraulic Disc
Suspension	Independent front suspension with leaf spring rear suspension
Batteries	Six 8V deep cycle
Frame	Welded Steel
Instrumentation	Digital display
Mirrors	Side Mirrors
Safety Features	Seat belts, horn, and reflectors
Charger	On-Board Charger
Ground Clearance	4.5 inches
Top Speed	25 mph