FireMagic Aurora - User Manual

1
IMPORTANT:
READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE.
DANGER:
IF YOU SMELL GAS:
1. Shut off the gas to the appliance.
2. Extinguish any open fl ame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your
gas supplier or the fi re department.
WARNING:
1. Do not store or use gasoline or other
fl ammable vapors and liquids in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
CODE AND SUPPLY REQUIREMENTS: This grill
must be installed in accordance with local codes
and ordinances, or, in the absence of local codes,
with either the latest National Fuel Gas Code
(ANSI Z223.1/NFPA 54), and Natural Gas and
Propane Storage and Handling Installation Code
(CSA-B149.1).
This appliance and its dedicated manual shutoff
valve must be disconnected from the gas-supply
piping system when testing the system at pressures
in excess of ½ psig (3.5 kPa).
This appliance must be isolated from the gas-supply
piping system by closing its dedicated manual
shutoff valve during any pressure testing of the gas-
supply system at pressures up to and including ½
psig (3.5 kPa).
All electrical outlets in the vicinity of the grill must be
properly grounded in accordance with local codes,
or, in the absence of local codes, with the National
Electrical Code, ANSI/NFPA 70, or the Canadian
Electrical Code, CSA C22.1, whichever is applicable.
Keep all electrical-supply cords and fuel-supply
hoses away from any heated surface.
Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746
INSTALLER: Leave these instructions with consumer.
CONSUMER: Retain for future reference.
WARNING:
Improper installation, adjustment,
alteration, service, or maintenance can
cause injury or property damage. For
proper installation, refer to the installation
instructions. For assistance or additional
information, consult a qualifi ed professional
service technician, service agency, or the
gas supplier.
SAFETY AND WARNING CODES
STAND-ALONE POST OUTDOOR
GAS GRILLS
INSTALLATION
INSTRUCTIONS AND
OWNER’S MANUAL
Proper operation of your grill requires
prompt and periodic maintenance.
See the CARE & CLEANING section
for details.
Certifi ed to: ANSI Z21.58-2015
CSA 1.6-2015
11-093
US
®
C
REV 1 - 1603020805
L-C2-436
A430s (IN-GROUND AND PATIO MOUNT)
A430s Patio
mount w/ analog
thermometer
shown

FireMagic Aurora Specifications

General

Grill Type	Built-In
Ignition System	Electronic
Material	Stainless Steel
Cooking Grid Material	Stainless Steel
Fuel Type	Natural Gas or Propane
Warranty	Lifetime on Stainless Steel Components

Summary

Safety and Warning Codes

Gas Leak Safety Procedures

Critical steps to take immediately if you smell gas.

Flammable Material Storage Warning

Warnings against storing flammable liquids and vapors near the appliance.

Code and Supply Requirements

Grill installation must comply with local and national gas codes.

Electrical Outlet Safety

Requirements for grounding electrical outlets in the grill's vicinity.

Getting Started

Electrical Safety Precautions

Guidelines to prevent electric shock during operation and cleaning.

Installation Requirements Overview

Model Specifications (cont.)

Grill Wiring Diagram

Schematic illustrating electrical connections for the grill components.

Grill Maintenance and Safety

Safe Operation and Cleaning

Electrical Connection Guidelines

Specific instructions for connecting the grill to a power source.

Installation Requirements

Overhead Construction Clearances

Minimum safe distances required from overhead structures.

Side and Rear Wall Clearances

Minimum clearances needed from side and rear walls.

Installation Requirements (cont.)

Combustion Airflow and Ventilation

Ensuring proper airflow for optimal grill performance and safety.

Gas Supply Plumbing

Requirements for connecting the gas supply line and valves.

Propane Safety Information

Propane Gas Handling Guidelines

Critical safety rules for using propane gas with the grill.

Propane Tank Installation Safety

Safety measures for installing and positioning propane tanks.

Propane Gas Cylinder Use

Cylinder and Connector Requirements

Specifications for propane cylinders, valves, and hoses.

Quick Coupler Operation

Patio Mount Installation

Preparing for Patio Mount

Routing Power and Gas Lines

Patio Mount Installation (cont.)

Connecting Gas Supply and Leak Testing

Procedures for connecting gas and performing leak tests.

Securing the Patio Mount Base

In-Ground Post Installation

Preparing for In-Ground Installation

Routing Underground Gas Supply

In-Ground Post Installation (cont.)

Attaching Post Extension and Pouring Concrete

Connecting Gas Supply and Power

Final gas and power connections for in-ground installation.

Routing Above-Ground Gas Supply

Leak Testing and Reconnecting Wires

Performing leak tests and reconnecting electrical components.

Lighting Instructions

Electronic Ignition Procedure

Manual Ignition Procedure

Shutting Off the Grill

Optional Digital Thermometer

Optional Digital Thermometer Settings

Setting Oven and Meat Temperatures

Optional Digital Thermometer Settings (cont.)

Optional Infrared Burner Operation

Infrared Burner Usage Guidelines

Care and Cleaning Procedures

Interior and Exterior Cleaning

Gas Type Conversion

Regulator and Orifice Conversion

Connecting to New Gas Supply

Gas Type Conversion (cont.)

Backburner and Infrared Orifice Conversion

Burner Air Shutter Adjustment

Adjusting Main Burner Air Shutters

Burner Air Shutter Adjustment (cont.)

Adjusting Backburner Air Shutters

Troubleshooting Guide

Ignition System Issues

Diagnosing and resolving problems with the ignition system.

Flame and Heat Issues

Troubleshooting low flame, insufficient heat, and uneven heating.