Fuji Electric Micro Control X User Manual

Thank you for purchasing the Fuji module type temperature controller.
2QFH\RXKDYHFRQ¿UPHGWKDWWKLVLVWKHSURGXFW\RXRUGHUHGSOHDVHXVHLWLQDFFRUGDQFHZLWKWKHIROORZLQJ
instructions.
)RUGHWDLOHGLQIRUPDWLRQRQRSHUDWLQJWKLVHTXLSPHQWSOHDVHUHIHUWRWKHVHSDUDWHXVHUVPDQXDO
,QDGGLWLRQSOHDVHNHHSWKLVLQVWUXFWLRQPDQXDOZLWKLQHDV\UHDFKRIWKHDFWXDOSHUVRQXVLQJWKLVHTXLSPHQW
Please Read First (Safety Information)
Please read this section thoroughly before using and observe the mentioned safety warnings fully.
Safety warnings are categorized as “Warning” or “Caution”. Failure to follow the instructions may
result in a safety hazard.
Warning
PLVKDQGOLQJPD\OHDGWRPLQRURUVHULRXVSHUVRQDOLQMXU\¿UHDQGRUSURSHUW\GDPDJH
Caution
Mishandling may cause injury to the user or property damage.
,IWKHHTXLSPHQWLVXVHGLQDPDQQHUQRWVSHFL¿HGE\WKHPDQXIDFWXUHUWKHSURWHFWLRQSURYLGHGE\WKH
equipment may be impaired.
1. Warning
1-1. Limitations in Use
This product is a temperature controller which was developed, designed and manufactured on the
premise that it would be used for general machinery.
In particular, if this product is to be used for applications that require the utmost safety as described
below, please take into consideration of the safety of the entire system and the machine by adopting
such means as a fail-safe design, a redundancy design as well as the conducting of periodical
inspections.
 6DIHW\GHYLFHVIRUWKHSXUSRVHRISURWHFWLQJWKHKXPDQERG\
 'LUHFWFRQWURORIWUDQVSRUWDWLRQHTXLSPHQW
 $LUSODQHV
 6SDFHHTXLSPHQW
 $WRPLFHTXLSPHQWHWF
Please do not use this product for applications which directly involve human lives.
CAUTION
The contents of this manual are subject to change without notice.
This manual is complied with possible care for the purpose of accuracy, however,
Fuji Electric shall not be held liable for any damages, including indirect damage, caused by
typographical errors,
absence of information or use of information in this manual.
1-2. Installation and Wiring
Ź 7KLVHTXLSPHQWLVLQWHQGHGWREHXVHGXQGHUWKHIROORZLQJFRQGLWLRQV
$PELHQWWHPSHUDWXUH -10 °C to 50 °C
$PELHQWKXPLGLW\ 90% RH or below (with no condensation)
Overvoltage category II
by IEC 61010-1
Pollution degree 2
Recommended fuse
9$&$77LPH/DJIRUWR9$&3RZHUVXSSO\
9'&9$&$77LPH/DJIRU9'&9$&3RZHUVXSSO\
Usage environment Indoor use
Ź ,IDFFHVVLEOH6DIHW\([WUD/RZ9ROWDJH6(/9FLUFXLWVDUHWREHFRQQHFWHGWR6LJQDOLQSXWWHUPLQDO
665'ULYHRXWSXWWHUPLQDO &XUUHQW RXWSXWWHUPLQDORU&RPPXQLFDWLRQ56WHUPLQDOHQVXUH
WRSURYLGHDEDVLFLQVXODWLRQ EHWZHHQWKH6(/9FLUFXLWVDQGWKHVHWHUPLQDOV)RUH[DPSOH XVH
transformer which has a basic insulation or higher degree of insulation). The basic insulation
requires a clearance at least 1.5 mm and a creepage of at least 3.0 mm. If such insulation is not
SURYLGHGWKH8/DQG(1VDIHW\FRPSOLDQFHPD\EHFRPHLQYDOLG
Ź)RU9 '&$& SRZHUVXSSO\PRGHOLIWKHHTXLSPHQW LV FRQQHFWHGWRWKH6DIHW\([WUD/RZ
9ROWDJH6(/9FLUFXLWDEDVLFLQVXODWLRQ PXVWEHSURYLGHGEHWZHHQWKH6(/9FLUFXLWDQGWKH
SRZHULQSXWWHUPLQDOV2WKHUZLVHWKHSRZHULQSXWWHUPLQDOVPXVWEHFRQQHFWWR([WUD/RZ9ROWDJH
(/9FLUFXLWVRDVWRSUHYHQWWKHHOHFWULFVKRFN
Ź )RU&7LQSXWXVH&XUUHQW7UDQVIHUZKLFKKDVVSHFL¿FDWLRQDVVKRZQEHORZLQRUGHUWRSUHYHQWWKH
HOHFWULFVKRFNDQGVSUHDGRI¿UH
1) Over Voltage Category II
3ROOXWLRQ'HJUHH 2
3) Required level of Insulating
%$6,&,168/$7,216833/<0(17$5<,168/$7,21
RU5(,1)25&(',168/$7,21
0D[LPXP9ROWDJHOLQHWRQHXWUDO 300Vac rms or 300Vdc
$ERXWVDIHW\VWDQGDUG
Please observe the following instructions to meet the requirements of safety standard.
Failure to observe these instructions violates safety standards. (This product is not a safety equipment.)
………………………………………………………………………………………………………………………………
Ɣ,QVWDOODUHFRPPHQGHGIXVHZKLFKLVVSHFL¿HGLQWKHLQVWUXFWLRQPDQXDOEHWZHHQWKHH[WHUQDOPDLQSRZHU
(mains circuit) and this equipment.
Ɣ,IDFFHVVLEOH6DIHW\([WUD/RZ9ROWDJH6(/9FLUFXLWVDUHWREHFRQQHFWHGWR6LJQDOLQSXWWHUPLQDO665
'ULYHRXWSXWWHUPLQDO&XUUHQWRXWSXWWHUPLQDORU&RPPXQLFDWLRQ56WHUPLQDOHQVXUHWRSURYLGHD
EDVLFLQVXODWLRQEHWZHHQWKH6(/9FLUFXLWVDQGWKHVHWHUPLQDOV)RUH[DPSOHXVHWUDQVIRUPHUZKLFKKDVD
basic insulation or higher degree of insulation). The basic insulation requires a clearance at least 1.5 mm
DQGDFUHHSDJHRIDWOHDVWPP,IVXFKLQVXODWLRQLVQRWSURYLGHGWKH8/DQG(1VDIHW\
compliance may become invalid.
Ɣ:KROHWKLVHTXLSPHQWPXVWEHPRXQWHGLQDQHQFORVXUHLQRUGHUWRSUHYHQWWKHHOHFWULFVKRFNDQGVSUHDG
RI¿UH
Ɣ%HVXUHWRLQVWDOODQDSSURSULDWHH[WHUQDOSURWHFWLYHFLUFXLWWRSUHYHQWH[FHVVLYHWHPSHUDWXUHULVHHWF
Ɣ:KHQSHUIRUPLQJZLULQJZRUNEHVXUHWRWXUQWKHSRZHURIIDQGWRZHDUSURWHFWLRQJORYHVRUVDIHW\JODVVHV
to prevent an electric shock.
Ɣ6HWSURSHUSDUDPHWHULQSXWVLJQDOVZKLFKFRUUHVSRQGWRHDFKLQSXWWREHFRQQHFWHG%HFDUHIXOQRWWR
confuse voltage input with current input, or vice versa.
Ɣ'RQRWXVHWKLVHTXLSPHQWIRUWKHPHDVXUHPHQWRIFLUFXLWVZKLFKIDOOVXQGHUPHDVXUHPHQWFDWHJRULHV,,,,,
or IV.
Ɣ'RQRWXVHWKLVHTXLSPHQWIRUPHDVXUHPHQWRIVLJQDOVWRZKLFKDYROWDJHRYHU9506RURYHU9'&LV
applied.
Ɣ,IWKHUHLVDULVNWKDWDQ\RQHPD\FRPHLQWRFRQWDFWZLWKWKHWHUPLQDOZKLOHWKHLQVWUXPHQWLVEHLQJ
energized, attach the terminal cover (optional) to prevent an electric shock. Before removing a terminal
cover, turn off all the power.
………………………………………………………………………………………………………………………………
Ź 1RWHWKDWWKHLQVXODWLRQFODVVIRUWKLVHTXLSPHQWLVDVIROORZV%HIRUHLQVWDOOLQJSOHDVHFRQ¿UPWKDW
the insulation class for equipment meets usage requirements.
Internal circuit
Process value input
Remote SV input
CT input
Valve position feedback
(PFB) input
Control output 1
(SSR drive, current, voltage)
Valve position feedback
(PFB) input
Control output 1
(SSR drive, current, voltage)
Control output 2 (SSR drive, current,
voltage) or Transfer output
Control output 2 (SSR drive, current,
voltage) or Transfer output
Digital input 1 to 5
Communication (RS-485)
Power supply (100 to 240V AC)
Control output 1 (relay contact)
or
Motorized valve OPEN output
Control output 2 (relay contact)
or
Motorized valve CLOSE output
Alarm output 1
(relay contact)
Alarm output
1 to 3
(relay contact)
Alarm output 2
(relay contact)
Control output 1 (relay contact)
or
Motorized valve OPEN output
Control output 2 (relay contact)
or
Motorized valve CLOSE output
Alarm output 1
(relay contact)
Alarm output
1 to 3
(relay contact)
Alarm output 2
(relay contact)
Basic insulation (1500 V AC) Functional insulation (500 V AC) No insulation
(1) (2) (1) (2)
Internal circuit
Process value input
Remote SV input
CT input
Digital input 1 to 5
Communication (RS-485)
Power supply (24V DC/24V AC)
Alarm output 4 and 5 (relay contact) Alarm output 4 and 5 (relay contact)
(1):When the 9th code is "J" AL 1 and 2: independent common
(2):When the 9th code is other than "J" AL 1 to 3: shared common
Ɣ$SRZHUVZLWFKRUDFLUFXLWEUHDNHUVKRXOGEHLQVWDOOHGZLWKLQWKHSRZHUVXSSO\IDFLOLW\
Ɣ$SRZHUVZLWFKRUDFLUFXLWEUHDNHUVKRXOGEHSURSHUO\LQVWDOOHGZLWKLQHDV\UHDFKRIDQRSHUDWRU
Ɣ$SRZHUVZLWFKRUDFLUFXLWEUHDNHUVKRXOGEHLGHQWL¿HGDVWKHRQHIRUWKLVSURGXFW
Ɣ(OHFWULFDOZLULQJPXVWEHPDGHE\WKHTXDOL¿HG SHUVRQQHORQO\DQGLQDFFRUGDQFHZLWK\RXU ORFDO
and national standards.
Ɣ)RUSRZHUVXSSO\ZLULQJXVHZLUHHTXDOWR9YLQ\OLQVXODWHGZLUHRUDERYH
Ɣ7RSUHYHQWGDPDJHDQGIDLOXUHRIWKHHTXLSPHQWSURYLGHWKHUDWHGSRZHUYROWDJH
Ɣ7RSUHYHQWVKRFNDQGHTXLSPHQWIDLOXUHGRQRWWXUQWKHSRZHU21XQWLODOOZLULQJLVFRPSOHWH
Ɣ%HIRUHWXUQLQJRQSRZHUFRQ¿UPWKDWFOHDUDQFHVSDFHKDVEHHQVHFXUHGWRSUHYHQWVKRFNRU¿UH
Ɣ'RQRWWRXFKWKHWHUPLQDOZKLOHWKHPDFKLQHLVRQ'RLQJVRULVNVVKRFNRUHTXLSPHQWHUURUV
Ɣ1HYHUGLVDVVHPEOHFRQYHUWPRGLI\RUUHSDLUWKLV HTXLSPHQW 'RLQJVRULVNVDEQRUPDORSHUDWLRQ
VKRFNRU¿UH
Ɣ,IDQ\IDLOXUHRFFXUVSOHDVHFRQWDFWWKHPDQXIDFWXUHUDQGUHWXUQWKHSURGXFW
Ɣ2XWSXWUHOD\LVWKHSDUWKDVDOLPLWHGOLIH:KHQRXWSXWUHOD\FRQWDFWFRPHVWRWKHHQGRILWVOLIHLW
might remain on-state, or off-state. For safety, use a protective circuit outside.
Ɣ7KH IDFWRU\GHIDXOWVHWWLQJRIWKLVHTXLSPHQW LV DVIROORZV&KDQJHWKHVHWWLQJDVQHFHVVDU\ VR
as the equipment to meet your application. Please note that the improper settings may result in
RYHUKHDWRUXQH[SHFWHGGDPDJH
 )RUWKHGHWDLOVRIRSHUDWLRQUHIHUWRWKHVHSDUDWHYROXPH2SHUDWLRQ0DQXDO,1371$(
Control output 1: heating control
Control output 2 (optional): cooling control
 $ODUPRXWSXWRSWLRQDOQRDODUP
 $ODUPRXWSXWRSWLRQDOQRDODUP
 $ODUPRXWSXWRSWLRQDOQRDODUP
 $ODUPRXWSXWRSWLRQDOQRDODUP
 $ODUPRXWSXWRSWLRQDOQRDODUP
Ɣ6\PEROVRQWKHLQVWUXPHQW
: Read this instruction manual thoroughly before using the product, and usethe product safely.
1-3. Maintenance
Ɣ:KHQ LQVWDOOLQJRUUHPRYLQJWKHHTXLSPHQWWXUQWKH SRZHU 2))2WKHUZLVHVKRFNRSHUDWLRQDO
errors or failures may be caused.
Ɣ3HULRGLFPDLQWHQDQFHLVUHFRPPHQGHGIRUFRQWLQXRXVDQGVDIHXVHRIWKLVHTXLSPHQW
Ɣ6RPHSDUWVLQVWDOOHGRQWKLVHTXLSPHQWKDYHDOLPLWHGOLIHDQGRUPD\GHWHULRUDWHZLWKDJH
Ɣ7KHZDUUDQW\SHULRGIRUWKLVXQLWLQFOXGLQJDFFHVVRULHVLVWKUHH\HDUVDIWHUWKHGDWHRIPDQXIDFWXUH
if the product is used properly.
&RQ¿UPLQJ6SHFL¿FDWLRQVDQG$FFHVVRULHV
Before using the product, confirm that it
matches the type ordered.
(For model code, please refer to pages 22 - 23.)
&RQ¿UPWKDWDOORIWKHIROORZLQJDFFHVVRULHVDUH
included.
Temperature Controller 1 unit
Instruction Manual 1 cop
y
Panel mounting adapter 2 pc
Waterproof packing 1 pc
Related Information
Refer to the following reference materials
for details about the items described in this
manual.
'RFXPHQW 5HIHUHQFH1R
'DWDVKHHW
('6
('6
Micro Controller (Model: PXF)
Operation Manual
,1371$(
Micro Controller (Model: PXF)
Communication Functions
0DQXDO02'%86
,1371$(
The latest manuals can also be downloaded at the
IROORZLQJ85/
KWWSZZZIXMLHOHFWULFFRPSURGXFWVLQVWUXPHQWV
Option
1DPH Quantity 2UGHU1R
Terminal cover* 1 pc ZZPPXF1-B100
PC loader
communication cable
1 cable ZZP*TQ501923C3
Shunt resistor

1 pc ==33;5$
*For PXF9, two terminal covers are necessary for one unit.
Model : PXF5/9
Micro Control X
Instruction Manual
INP-TN2PXF5/9d-E
Global Sales Section
Instrumentation & Sensors Planning Dept.
1, Fuji-machi, Hino-city, Tokyo 191-8502, Japan
http://www.fujielectric.com
Phone: +81-42-514-8930 Fax: +81-42-583-8275
http://www.fujielectric.com/products/instruments/
- 1 -

Fuji Electric Micro Control X Specifications

General

Brand	Fuji Electric
Model	Micro Control X
Category	Controller
Language	English