Fuji Electric Micro Control X User Manual

2. Caution
2-1. Cautions when Installing
Please avoid installing in the following locations.
Ɣ/RFDWLRQVLQZKLFKWKHDPELHQWWHPSHUDWXUHIDOOVRXWVLGHWKHUDQJHRI±WR&ZKHQHTXLSPHQW
LVLQXVH,IWKH SRZHU VXSSO\LV9$& WKHUHFRPPHQGHGPD[LPXPDPELHQWWHPSHUDWXUHLV
&
Ɣ/RFDWLRQVZLWKUDSLGWHPSHUDWXUHFKDQJHVOHDGLQJWRGHZFRQGHQVDWLRQ
Ɣ/RFDWLRQVZLWKFRUURVLYHJDVHVHVSHFLDOO\VXO¿GHJDVDPPRQLDHWFRUÀDPPDEOHJDVHV
Ɣ/RFDWLRQVZLWKYLEUDWLRQRUVKRFNGLUHFWO\9LEUDWLRQDQGVKRFNPD\FDXVHRXWSXWUHOD\PDOIXQFWLRQ
Ɣ/RFDWLRQVLQFRQWDFWZLWKZDWHURLOFKHPLFDOVVWHDPRUKRWZDWHU
(If the equipment gets wet, there is a risk of electric shock or fire, so have it inspected by Fuji
distributor.)
Ɣ/RFDWLRQVZLWKKLJKFRQFHQWUDWLRQVRIDWPRVSKHULFGXVWVDOWRULURQSDUWLFOHV
Ɣ/RFDWLRQVZLWKODUJHLQGXFWLYHLQWHUIHUHQFHUHVXOWLQJLQVWDWLFHOHFWULFLW\PDJQHWLF¿HOGVRUQRLVH
Ɣ/RFDWLRQVLQGLUHFWVXQOLJKW
Ɣ/RFDWLRQVWKDWEXLOGXSKHDWIURPUDGLDQWKHDWVRXUFHVHWF
Recommended site conditions
Ɣ$SODFHZKHUHWKHDPELHQWKXPLGLW\GXULQJRSHUDLRQLVEHWZHHQWR5+
$ERXW(0&VWDQGDUG
Ɣ7KLVHTXLSPHQWLVDFODVV$IRULQGXVWULDOORFDWLRQVHTXLSPHQW'RQRWXVHWKLVHTXLSPHQWLQGRPHVWLF
establishment, such as residential areas, or it may cause radio interference. If you use this equipment in
domestic locations, take adequate measures on the outside of the equipment to reduce radio interference.
Ɣ8QGHUWKHUHTXLUHPHQWRI(0&VWDQGDUGWKHPD[LPXPOHQJWKRIH[WHUQDOFDEOHLQFOXGLQJDVHQVRUWREH
FRQQHFWHGWRWKLVHTXLSPHQWLVP'RQRWFRQQHFWWKHVHQVRUORQJHUWKDQP
2-2. Cautions when Attaching to the Panels
Ɣ3OHDVH DWWDFK WKH3;)3;)ZLWKWKHLQFOXGHGIL[WXUHV SLHFHV WRWKHWRSDQGERWWRPDQG
tighten with a screwdriver.
Ɣ7KHFODPSWRUTXHLVDSSUR[LPDWHO\1PNJFP
 ,WLVGHVLJQHGVXFKWKDWRYHUWLJKWHQLQJZLOOFDXVHOHIWULJKWFUDFNLQJWRWKHFHQWUDODUHDRIWKH)L[WXUHV
and hence reduce the torque.
Cracking to the central area will not cause any problems in terms of usability of the equipment.
 +RZHYHUGRH[HUFLVHFDXWLRQLQ QRW DSSO\LQJWRRPXFKWRUTXHEHFDXVHWKHFDVLQJ LV PDGHRI
plastic.)
Ɣ7KHIURQWRIWKLVHTXLSPHQWLVZDWHUSURRILQFRPSOLDQFHZLWK1(0$;VWDQGDUGV,3HTXLYDOHQW
To effect waterproof, the included packing is shall be attached between the controller and the
panel according to the guidelines below. (Incorrect attachment may cause the equipment to lose its
waterproof capabilities.)
 $VVKRZQLQ)LJLQVHUWWRWKHSDQHODIWHUDWWDFKLQJWKHSDFNLQJWRWKHHTXLSPHQWFDVH
 $VVKRZQLQ)LJWLJKWHQWKH¿[WXUHVFUHZVVRWKDWQRJDSVFDQUHPDLQEHWZHHQWKHHTXLSPHQW
IDFHWKHSDFNLQJDQG WKH SDQHOV2QFH¿QLVKHGFRQ¿UPWKDWWKHUHDUH QRFKDQJHVLQVKDSH
VXFKDVGLVSODFHGRULPSURSHUO\¿WWHGSDFNLQJHWFDVVKRZQLQ)LJ
Ɣ,IWKHSDQHOGRHVQRWKDYHHQRXJKVWUHQJWKJDSVPD\GHYHORSEHWZHHQWKHSDFNLQJDQGWKHSDQHO
WRORVHZDWHUSURR¿QJFDSDELOLWLHV
Fig. 1 Fig. 2 Fig. 3
Packing
Packing
Case
Case
(Bad)
(Good)
Unit
Front
Panel
Screw
Screw
Panel
Packing
Mounting fixture
Mounting fixture
$WWDFKPHQWRQYHUWLFDOVXUIDFH
(Horizontal attachment)
Caution
Ɣ ,QRUGHUWRDLGKHDWGLVVLSDWLRQGRQRWEORFNWKHVLGHVRIWKHHTXLSPHQW
Ɣ 'RQRWEORFNWKHDLUYHQWVRQWKHWRSDQGERWWRPRIWKHFDVH
Ɣ
)RU3;)SOHDVHDWWDFKWKH)L[WXUHVWRWKHDWWDFKPHQWKROHVLQWKHFHQWHURIWKHPDLQ
unit.
2-3. Cautions for Wiring
Ɣ)RUWKHUPRFRXSOHLQSXWXVHWKHGHVLJQDWHGFRPSHQVDWLRQOHDGIRUUHVLVWDQFHEXOELQSXWXVHZLUHV
with small lead wire resistance and without any resistance difference among the three wires.
Ɣ7RDYRLGQRLVHFRQGXFWRUHIIHFWVLQSXWVLJQDOZLUHVVKRXOGEHVHSDUDWHGIURPHOHFWULFSRZHUOLQHVRU
load lines.
Ɣ,QSXWVLJQDOZLUHDQGRXWSXWVLJQDOZLUHVKRXOGEHVHSDUDWHGHDFKRWKHU$QGERWKVKRXOGEHVKLHOG
wire.
Ɣ,IWKHUHLVDORWRIQRLVHIURPWKHSRZHUVRXUFHDGGLQJDQLQVXODWLRQWUDQVGXFHUDQGXVLQJDQRLVH
¿OWHULVUHFRPPHQGHG
 $OZD\VDWWDFKDQRLVH¿OWHUWRDSDQHOWKDWLVJURXQGHGVHFXUHO\DQGNHHSWKHZLULQJEHWZHHQWKH
QRLVH¿OWHURXWSXWVLGHDQGWKHPHDVXULQJHTXLSPHQWSRZHUWHUPLQDOZLULQJWRDPLQLPXPOHQJWK
 3OHDVHGRQRWDWWDFKIXVHVDQGVZLWFKHVHWFWRWKHQRLVH¿OWHURXWSXWZLULQJRWKHUZLVHWKH¿OWHU¶V
effectiveness will be decreased.
Ɣ7ZLVWLQJWKHSRZHUZLUHVLVHIIHFWLYHZKHQFRQQHFWLQJWKHZLUHV7KHVKRUWHUWKHSLWFKRIWKHWZLVW
the more effective the connection is against noise.)
Ɣ2SHUDWLRQSUHSDUDWLRQWLPHLVUHTXLUHGIRUWKHFRQWDFWRXWSXWZKHQSRZHULVWXUQHGRQ,IXVLQJLWDV
DVLJQDOWRDQH[WHUQDOLQWHUORFNFLUFXLWSOHDVHFRXSOHLWZLWKDGHOD\HGUHOD\
Ɣ&RQFHUQLQJWKHRXWSXWUHOD\FRQQHFWLQJWKHPD[LPXPUDWHGORDGZLOOVKRUWHQ
WKHSURGXFW¶VOLIHVRSOHDVHDWWDFKDQDX[LOLDU\UHOD\,IWKHRXWSXWRSHUDWLRQ
frequency is high, selecting a SSR drive output type is recommended.
[Proportionate cycles] Relay output: 30 seconds or more, SSR drive output:
1 second or more
Ɣ,I\RX VHOHFWHG WKHYHUVLRQZLWKWKHKHDWHUEUHDNDODUPXVH D FRPPRQ
power line for the heater and the controller.
Ɣ:KHQ LQGXFWLYH ORDGVVXFKDVPDJQHWLFRSHQLQJFORVLQJHTXLSPHQWHWF
as relay output equipment are connected, use of a surge absorber is
UHFRPPHQGHGLQRUGHUWRSURWHFW WKH FRQWDFWVDJDLQVWRSHQLQJFORVLQJ
surges and to ensure long-term use.
 5HFRPPHQGHGVSHFL¿FDWLRQIRUWKHVXUJHDEVRUEHU
Voltage 1RPLQDOYDULVWRUYROWDJH
100 V 9
200 V 9
 $WWDFKPHQWSRVLWLRQEHWZHHQWKHUHOD\FRQWURORXWSXWFRQWDFWV
(Example)
























.H\2SHUDWLRQ&DXWLRQV(UURU2SHUDWLRQV
Ɣ7KHDODUPIXQFWLRQGRHVQRWZRUNSURSHUO\ZKHQDQHUURUWDNHVSODFHXQOHVVWKHVHWWLQJVDUHPDGH
FRUUHFWO\$OZD\VYHULI\LWVVHWWLQJEHIRUHRSHUDWLRQ
Ɣ,I WKH LQSXWZLULQJEUHDNVWKHGLVSOD\ZLOOUHDG 8888 RU////:KHQUHSODFLQJWKHVHQVRU
always turn the power OFF.
2-5. Others
Ɣ3OHDVHGRQRWZLSHWKHHTXLSPHQWZLWKRUJDQLFVROYHQWVVXFKDVDOFRKRORUEHQ]HQHHWF,IZLSLQJ
is necessary, use a neutral cleaning agent.
Ɣ'RQRWXVHPRELOHSKRQHVQHDUWKLVHTXLSPHQWZLWKLQFP2WKHUZLVHDPDOIXQFWLRQPD\UHVXOW
Ɣ7URXEOHPD\RFFXULIWKHHTXLSPHQWLVXVHGQHDUDUDGLR79RUZLUHOHVVGHYLFH
Ɣ7KLVHTXLSPHQWVKRXOGEHWUHDWHGDVDQLQGXVWULDOZDVWHZKHQLWLVGLVSRVHGRI
)RU3URSHU8VDJH
Please con¿rm that the model delivered matches your order.
0RGHO6SHFL¿FDWLRQVSDJH
Terminal connections diaJram
"4 WirLQJSDJH
&KDQJLQJVHWvalue
Basic Operation Methods
Parameter List
Input/Output/Control
"5 Display and OperDWLRQVSDJH
"5 Display and OperDWLRQVSDJH
ParDPHWHU/LVWSDJHWR
)XQFWLRQVSDJH
6HWWLQJRILQSXWVHQVRUDQGLQSXWrDQJH
6HOHFWLQJFRQWUROPHWKRG
&RQWUROOLQJWKURXJKDXWRWXQLQJ
WRPDWLFVHWWLQJSDrameters
,QSXW6HWWLQJSDJH
&RQWURO6HWWLQJSDJH
AXWRWXQLQJSDJH
)X]]\3,'&RQWURO6HOIWXQLQJ&RQWUROSDJH
Display durLQJHTXLSPHQWHUURU
(UURU,QGLFDWLRQVSDJH
External dimensions
Panel cut dimensions
0RXQWLQJWKHSDQHO
,QVWDOODWLRQDQG0RXQWLQJSDJH
&RQ¿rmation of model code
2
Wiring Connection
3 Display and Operations
4 Parameter List
5 Functions of the Temperature Controller
Turn Power On
6 Advanced Usage
7 Error Indications
Operation
1 Installation and Mounting
Caution
Wait 30 minutes for the controller to stabilized thermally. Operations such as
measurements should be taken after the equipment has been on for 30 minutes
or more.
- 2 -

Fuji Electric Micro Control X Specifications

General

Brand	Fuji Electric
Model	Micro Control X
Category	Controller
Language	English