Fuji Electric Micro-Controller X Socket type Instruction Manual

&K3/73,'SDOHWWHSDUDPHWHUV
3DUDPHWHU
)XQFWLRQ 6HWWLQJUDQJH ,QLWLDOYDOXH 5HPDUNV
ʋ 'LVSOD\ 1DPH
100
SV1 Sets the SV (set value) 69OLPLWORZHU69/WR69OLPLWXSSHU69+
%FS
0%FS Note 1)
101
Proportional band 1 (%) Sets the proportional band. 0.1 to 999.9% 5.0%
102
Integration time 1 Sets the integration time. 0 to 3200 sec 240 sec
103 Differential time 1 Sets the differential time. 0.0 to 999.9 sec 60.0 sec
104
ON/OFF control hysteresis 1 6HWVWKHK\VWHUHVLVZKHQXVLQJWKH212))FRQWURO 0 to 50%FS 0.25%FS
105
Cooling proportional band 1 (%) Sets the cooling proportional band. 0.0 to 100.0 1.0
106 Dead band 1 (%) Sets the dead band -50.0 to 50.0% 0.0%
107
Output convergence value 1 (%) 2IIVHWYDOXHZKLFKLVDGGHGWRWKHFRQWURORXWSXW -100.0 to 100.0% 0/50 (single/dual)
108
$QWLUHVHWZLQGXS 6HWVWKHDQWLUHVHWZLQGXS 0 to 100%FS 100%FS
109 Normal/reverse 1 Selects single control or dual control.
Sets the control action (normal or reverse).
rv-- (heat (reverse)/cool (none))
no-- (heat (normal)/cool (none))
rvno (heat (reverse)/cool (normal))
norv (heat (normal)/cool (reverse))
rvrv (heat (reverse)/cool (reverse))
nono (heat (normal)/cool (normal))
rv--/rvno
(single/dual)
Note 2)
[RESET]





















160
SV 7 Sets the SV (set value) 69OLPLWORZHU69/WR69OLPLWXSSHU69+
%FS
0%FS Note 1)
161
Proportional band 7 (%) Sets the proportional band. 0.1 to 999.9% 5.0%
162
Integration time 7 Sets the integration time. 0 to 3200 sec 240 sec
163
Differential time 7 Sets the differential time. 0.0 to 999.9 sec 60.0 sec
164
ON/OFF control hysteresis 7 6HWVWKHK\VWHUHVLVZKHQXVLQJWKH212))FRQWURO 0 to 50%FS 0.25%FS
165
Cooling proportional band 7 (%) Sets the cooling proportional band. 0.0 to 100.0 1.0
166 Dead band 7 (%) Sets the dead band -50.0 to 50.0% 0.0%
167
Output convergence value 7 (%) 2IIVHWYDOXHZKLFKLVDGGHGWRWKHFRQWURORXWSXW -100.0 to 100.0% 0/50 (single/dual)
168
$QWLUHVHWZLQGXS 6HWVWKHDQWLUHVHWZLQGXS 0 to 100%FS 100%FS
169 Normal/reverse 7 Selects single control or dual control.
Sets the control action (normal or reverse).
rv-- (heat (reverse)/cool (none))
no-- (heat (normal)/cool (none))
rvno (heat (reverse)/cool (normal))
norv (heat (normal)/cool (reverse))
rvrv (heat (reverse)/cool (reverse))
nono (heat (normal)/cool (normal))
rv--/rvno
(single/dual)
Note 2)
[RESET]
170 3,'VZLWFKLQJSRLQW 6HWVWKH3,'VZLWFKLQJSRLQWIRUSDOHWWH 0 to 100%FS 0%FS





















176
3,'VZLWFKLQJSRLQW 6HWVWKH3,'VZLWFKLQJSRLQWIRUSDOHWWH 0 to 100%FS 0%FS
177
0D[69VHOHFWLRQQXPEHU &KRRVLQJ69ZLWKWKHXVHUNH\VHWVLWWRWKHPD[LPXP
possible number.
/R&/
Sv1
Sv2
Sv3
Sv4
Sv5
Sv6
Sv7
di (depending on DI)
Sv7
178 0D[3,'VHOHFWLRQQXPEHU &KRRVLQJ3,'ZLWKWKHXVHUNH\VHWVLWWRWKHPD[LPXP
possible number.
/R&/
Pid1
Pid2
Pid3
Pid4
Pid5
Pid6
Pid7
di (depending on DI)
Pid7
1RWH³6Y/´DQG³6YK´PXVWEHVHWVRWKDW6Y/6YK:KHQ\RXFKDQJHWKHYDOXHVIRU³6Y/´DQG³6YK´FKHFN69³6Y&K´WKURXJK69³6Y&K´
1RWH6HWWKHVDPHYDOXHDVWKHRQHIRUWKH1RUPDO5HYHUVHVHWWLQJ³U(Y&K´
&K35*UDPSVRDNSDUDPHWHUV
3DUDPHWHU
)XQFWLRQ 6HWWLQJUDQJH ,QLWLDOYDOXH 5HPDUNV
ʋ 'LVSOD\ 1DPH
200
Ramp soak operation pattern (Step No.) 6HWVZKLFKVWHSVWRXVHLQWKHUDPSVRDNRSHUDWLRQSDWWHUQ 0 (uses steps 1 to 8)
1(uses steps 9 to 16)
2(uses steps 17 to 24)
3(uses steps 25 to 32)
4(uses steps 33 to 40)
5(uses steps 41 to 48)
6(uses steps 49 to 56)
7(uses steps 57 to 64)
8(uses steps 1 to 16)
9(uses steps 17 to 32)
10(uses steps 33 to 48)
11(uses steps 49 to 64)
12(uses steps 1 to 32)
13(uses steps 33 to 64)
14(uses steps 1 to 64)
di (depending on DI)
14 Note 1)
201 Ramp soak time units Sets the units of the ramp soak time hh.MM (hour:min)
MM.SS (min:sec)
hh.MM
202 Ramp soak 1 seg/SV 1 Sets the SV 0 to 100%FS 0%FS
203 Ramp soak 1 seg ramp time Sets the ramp time. 00:00 to 99:59 (hour:min/min:sec) 00:00
204
Ramp soak 1 seg soak time Sets the soak time. 00:00 to 99:59 (hour:min/min:sec) 00:00
205 Ramp soak 2 seg/SV 2 Sets the SV 0 to 100%FS 0%FS
206
Ramp soak 2 seg ramp time Sets the ramp time. 00:00 to 99:59 (hour:min/min:sec) 00:00





















389 Ramp soak 63 seg ramp time Sets the ramp time. 00:00 to 99:59 (hour:min/min:sec) 00:00
390 Ramp soak 63 seg soak time Sets the soak time. 00:00 to 99:59 (hour:min/min:sec) 00:00
391 Ramp soak 64 seg/SV 64 Sets the SV 0 to 100%FS 0%FS
392 Ramp soak 64 seg ramp time Sets the ramp time. 00:00 to 99:59 (hour:min/min:sec) 00:00
393 Ramp soak 64 seg soak time Sets the soak time. 00:00 to 99:59 (hour:min/min:sec) 00:00
394
Ramp soak mode Sets the program operation method 0 to 15 0
395
Guaranty soak ON/OFF Sets the guaranty soak ON or OFF oFF (guaranty soak off)/on (guaranty soak on) oFF
396 *XDUDQW\VRDNEDQG/RZHU 6HWVWKHORZHUOLPLWRIJXDUDQW\VRDN 0 to 50%FS 1.25%FS
397 Guaranty soak band (Upper) Sets the upper limit of guaranty soak 0 to 50%FS 1.25%FS
398
PV start 6HWVZKHWKHURUQRWWRVWDUWUDPSVRDNZLWK39 oFF (PV start off)/on (PV start on) oFF
399
Restore mode 6HWVKRZWRUHVWDUWZKHQWKHFRQWUROOHULVUHVWRUHGDIWHUD
SRZHUORVV
rES (Reset)
Con (Continue)
ini (Restart)
rES
400 0D[SDWWHUQVHOHFWLRQ 6HWVWKHPD[LPXPSDWWHUQQXPEHUVHOHFWDEOHE\XVLQJWKH
user key.
0 to 14 14
401 Min pattern selection Sets the minimum pattern number selectable by using the
user key.
0 to 14 0
1RWH'RQRWFKDQJHWKLVSDUDPHWHUGXULQJWKHUDPSVRDNRSHUDWLRQ%HVXUHWRVHW³3U*´ ³R))´EHIRUHFKDQJLQJWKHSDUDPHWHU
- 9 -

Fuji Electric Micro-Controller X Socket type Specifications

General

Brand	Fuji Electric
Model	Micro-Controller X Socket type
Category	Temperature Controller
Language	English