Gardner Denver AUTOSENTRY EAU99Q - Figure 1-4 - Compressor; Motor Side; Figure 1-5 - Cooler; Reservoir Side

75 pages

Save Page as PDF

To Next Page

To Previous Page

13-9-666 Page 11

Figure 1-4 – COMPRESSOR / MOTOR SIDE

Figure 1-5 – COOLER / RESERVOIR SIDE

200EDM797-

(Ref. Drawing)

Main Page

Maintain Compressor Reliability and Performance with2
Genuine Gardner Denver Compressor Parts and Support Services2
Instructions for Ordering Repair Parts/Remanufactured Airends2
Warning - Prohibition - Mandatory Label Information3
Safety Precautions5
Table of Contents6
Index7
List of Illustrations9
Section 1, General Information10
Figure 1-1 - Compression Cycle10
Figure 1-2 - Starter Box11
Figure 1-3 - Control Box11
Figure 1-4 - Compressor / Motor Side12
Figure 1-5 - Cooler / Reservoir Side12
Figure 1-6 - Air/Oil Flow Diagram13
Section 2, Installation14
Figure 2-1 - Typical Compressor Room15
Figure 2-2 - Air Flow Chart15
Figure 2-3 - Cold Weather Installation17
Figure 2-4 - Inlet Line Lengths18
Figure 2-5 - Heat Exchanger (Oil Cooler) Approximate Water Flow20
Figure 2-6 - Aftercooler Approximate Water Flow20
Figure 2-7 - Series Piping22
Figure 2-8 - Parallel Piping22
Section 3, Starting & Operating Procedures25
Section 4, Controls & Instrumentation28
Figure 4-1 - Schematic Tubing Diagram29
Figure 4-2 - Blowdown Valve30
Figure 4-3 - Minimum Discharge Pressure/Check Valve30
Figure 4-4 - Inlet Valve31
Figure 4-5 - Shuttle Valve32
Figure 4-6 - Turn Valve - Electra-Saver Only33
Figure 4-7 - Control Schematic - Compressor Unloaded - Constant Speed Mode36
Figure 4-8 - Control Schematic - Compressor at Full Load - Constant Speed Mode37
Figure 4-9 - Control Schematic - Compressor Unloaded - Low Demand Mode or Auto Mode38
Figure 4-10 - Control Schematic - Compressor at Full Load39
Figure 4-11 - Control Schematic - Compressor Fully Unloaded - Low Demand Mode Switch off40
Figure 4-12 - Control Schematic - Compressor Fully Loaded - Low Demand Mode Switch on41
Figure 4-13 - Wiring Diagram - Wye Delta42
Figure 4-14 - Wiring Diagram - Full Voltage43
Figure 4-15 - Wiring Diagram - Wye Delta44
Figure 4-16 - Wiring Diagram - Full Voltage45
Section 5, Lubrication, Oil Cooler, Oil Filter & Separator46
Figure 5-1 - Dew Point Chart °F48
Figure 5-2 - Dew Point Chart °C48
Figure 5-3 - Flow Diagram - Air/Oil System49
Figure 5-4 - Oil Flow Diagram - Remote Overhead Mounted Cooler50
Figure 5-5 - Cooler Drain Detail51
Figure 5-6 - Oil Level Gauge54
Figure 5-7 - Oil Change Interval55
Figure 5-8 - Approximate Oil System Capacities56
Figure 5-9 - Thermostatic Mixing Valve Element58
Figure 5-10 - Water Control Valve59
Figure 5-11 - Oil Separator61
Section 6, Air Filter64
Figure 6-1 - Heavy Duty Air Filter64
Section 7, Coupling66
Figure 7-1 - Installation of Coupling Cushions66
Section 8, Maintenance Schedule69
Section 9, Troubleshooting71

Gardner Denver AUTOSENTRY EAU99Q - Figure 1-4 - Compressor; Motor Side; Figure 1-5 - Cooler; Reservoir Side

Table of Contents

Related product manuals