23
USE AND CARE INSTRUCTIONS
CORRECT LP GAS TANK USE
LP Gas grill models are designed for use with a 20
Ib or 30 lb. Liquid Propane Gas (LP Gas) tank, not
included with the grill. Never connect your gas grill to
an LP Gas tank that exceeds this capacity. A tank of
approximately 12-1/4" inches in diameter by 23-3/4"
inches high is the maximum size LP Gas tank to
use. You must use an "OPD" gas tank which
offers a listed Overfill Prevention Device. This safety
feature prevents tank from being overfilled which can
cause a malfunctioning of LP Gas tank, regulator
and/or grill.
Never connect an unregulated LP gas tank to your
gas grill. The gas regulator assembly supplied with
your gas grill is adjusted to have an outlet pressure
of 11" water column (W.C.) for connection to an LP
gas tank. Only use the regulator and hose assembly
supplied with your gas grill. Replacement regulators
and hose assemblies must be those specified by
the Manufacturer.
Have your LP Gas dealer check the release valve
after every filling to ensure it remains free of defects.
Always keep LP Gas tank in upright position.
Do not subject the LP Gas tank to excessive heat.
Never store an LP Gas tank indoors. If you store
your gas grill in the garage always disconnect the
LP Gas tank first and store it safely outside.
LP Gas tanks must be stored outdoors in a well-
ventilated area and out of the reach of children.
Disconnected LP Gas tanks must not be stored in a
building, garage or any other enclosed area.
The regulator and hose assembly can be seen after
opening the doors (if applicable) and must be
inspected before each use of the grill. If there is
excessive abrasion or wear or if the hose is cut, it
must be replaced prior to using the grill again.
Any attempt to convert the grill from one fuel type
to another is extremely hazardous and must be
performed by a qualified gas technician only, using
a NG Conversion Kit purchased from Grand Hall.
Never light your gas grill with the lid closed or
before checking to ensure the burner tubes are fully
seated over the gas valve orifices.
The LP Gas tank must be constructed and marked
in accordance with the Specifications for LP-Gas
Cylinders of the U.S. Department of Transportation
(D.O.T.) or the National Standard of Canada, CAN/
CSA-B339, Cylinders, Spheres and Tubes for
Transportation of Dangerous Goods; and Commis-
sion, as applicable.
The LP Gas tank must have a shutoff valve,
terminating in an LP Gas supply tank valve outlet,
that is compatible with a Type 1 tank connection
device. The LP Gas tank must also have a safety
relief device that has a direct connection with the
vapor space of the tank.
The tank supply system must be arranged for vapor
withdrawal.
The LP Gas tank must have a collar to protect the
tank valve.
Never allow children to operate your grill. Do not allow
children or pets to play near your grill. Always supervise
children and pets if they are in the vicinity of the unit.
Use of alcohol, prescription or non-prescription drugs
can impair your ability to properly assemble and
safely operate your grill.
Keep fire extinguisher readily accessible. In the event
of a oil/grease fire, do not attempt to extinguish with
water. Use type B extinguisher or smother with dirt,
sand or baking soda.
In the event of rain, cover the grill and turn off the burner
and gas supply.
Use your grill on a level, stable surface in an area clear
of combustible materials.
Do not leave grill unattended when in use.
Do not move the appliance when in use.
Allow the grill to cool before moving or storing.
Do not use your grill as a heater.
This grill is not intended to be installed in or on
recreational vehicles and/or boats.
The grill is not intended for commercial use.
Never use charcoal in this gas grill.
!
Do not store a spare LP-Gas tank under or near
this appliance.
Never fill the tank beyond 80 percent full; and
If the information in "(a)" and "(b)" is not followed
exactly, a fire causing death or serious injury may
occur.
A.
B.
C.
Use your grill at least 3 feet away from any
wall or surface. Use your grill at least 3 feet away
from combustible objects that can melt
or catch fire such as vinyl or wood siding, fences
and overhangs or sources of ignition including
pilot lights on water heaters and live electrical
appliances.
Outdoor cooking gas appliance shall not be used
under overhead combustible construction.
Never use your gas grill in a garage, porch, shed,
breezeway or any other enclosed area.
Never obstruct the flow of ventilation air around
your gas grill housing.
In windy conditions, always position the front of
the grill to face oncoming wind to reduce heat
and smoke from blowing in your face and to
prevent potential serious injury or grill damage.
•
•
•
•
!
•
WARNING
!
WARNING
!
WIND
DIRECTION
3ft.
3ft.
To Next Page
Loading...
