Grant Vortex - Page 2

Page 2
IMPORTANT NOTE FOR INSTALLERS
These instructions are intended to guide installers on the
installation, commissioning and servicing of the Eurofl ame
condensing oil boiler. After installing the boiler, leave these
instructions with the user.
A user handbook is available to guide users in the operation of the
oil boiler.
SPECIAL TEXT FORMATS
The following special text formats are used in these instructions
for the purposes listed below:
! WARNING !
Warning of possible human injury as a consequence of not
following the instructions in the warning.
! CAUTION !
Caution concerning likely damage to equipment or tools
as a consequence of not following the instructions in the
caution.
! NOTE !
Used for emphasis or information not directly concerned
with the surrounding text but of importance to the reader.
PRODUCT CODES AND SERIAL NUMBERS
COVERED
The serial numbers used on Grant oil boilers consist of a fi fteen
digit numerical code with the fi nal three digits being the product
identifi er.
For example:
100000200218760
These instructions cover the following product codes and serial
numbers:
Product code Serial number identifi er
EFCON5090BHBSRED 592
EFCON90120BHBSRED 548
VORTBH5090BSRED 560
VORTBH90120BSRED 561
VORTBH120155BSRED 559
VORTBH155240BSRED 598
SERVICING
The boiler should be serviced at least every twelve months and
the details entered in the Service Log in the user handbook.
FUEL TYPE
All Grant Eurofl ame boilers are suitable for use with Class C2
Kerosene.
The use of Class D Gas Oil on all Grant Eurofl ame Low NOx and
Blue Flame boilers DOES NOT comply with ErP requirements or
EU regulations, and as a result Grant does not condone its use.
To use Bio-Kerosene (B30K), refer to the information below:
OPERATION ON BIO-FUEL
All Grant condensing boilers manufactured since May 2011 are
suitable for operation on both standard Kerosene (Class C2 to BS
2869) and also bio-kerosene - up to a 30% blend (B30K).
All burner settings and nozzle sizes (as detailed in Section 2.3 of
these instructions) are correct for both standard kerosene and bio-
kerosene (B30K).
In order to operate this boiler on bio-kerosene, it will be necessary
to take the following actions:
• Use a bio-kerosene (B30K) compatible fl exible oil line in
place of the oil line supplied with the boiler.
• Have the oil storage tank and oil supply line (including all
pipework, sight gauges, fi lters, isolating valves, fi re valves,
de-aeration devices, etc.) checked for their compatibility with
bio-kerosene (B30K).
Where necessary, some or all of these items may have to be
replaced with a bio-kerosene compatible alternative.
• Check the suitability of the fl ue system with Grant.
• Use only bio-kerosene (B30K) that conforms to OPS24.
IMPORTANT:
Under no circumstances, should the boiler be used with
bio-kerosene without the above actions being taken fi rst.
! NOTE !
This appliance can be used by children
aged from 8 years and above and persons
with reduced physical, sensory or mental
capabilities or lack of experience and
knowledge if they have been given
supervision or instruction concerning
use of the appliance in a safe way and
understand the hazards involved.
Children shall not play with the appliance.
Cleaning and user maintenance shall not
be made by children without supervision.
This manual is accurate at the date of printing but will be superseded and should be disregarded if specifi cations and/or appearances are changed in the interests of continued product improvement.
However, no responsibility of any kind for any injury, death, loss, damage or delay however caused resulting from the use of this manual can be accepted by Grant Engineering (Ireland) ULC, the
author or others involved in its publication.
All good sold are subject to our o󰀩 cial Conditions of Sale, a copy of which may be obtained on application.
© Grant Engineering (Ireland) ULC No part of this manual may be reproduced by any means without prior written consent.
GRANT ENGINEERING (IRELAND) ULC
Crinkle, Birr, Co O󰀨 aly
R42 D788, Ireland
www.grant.eu
Email: info@grantengineering.ie
Tel:+353 (0)57 91 20089