Heatmor 100 CSS

To Next Page

To Previous Page

07/12/2011

Name and Address

See inside of front door for data plate that has model information

Model: _________________________________________________________________

Referred By: ___________________________________________________________________________________________

Main Page

Default Chapter3
- Table of Contents3
Dear Heatmor™ Owner6
Notice to the Reader7
Certificate of Compliance8
1 Heatmor™ Stainless Steel Furnace Models10
2 Furnace Specifications11
3 Front Cut Away View of Heatmor™ Outdoor Furnace12
- Furnace Parts List13
4 Rear Cut Away View of Heatmor™ Outdoor Furnace14
- Furnace Parts List15
5 Minimum Clearance Separation Specifications16
6 Warnings and Precautions17
- A Installation17
- B Electrical18
- C Other18
7 Concrete Pad Specifications19
8 Installation of the Heatmor™ Furnace22
- A Equipment Required22
- B Placing the HEATMOR™ on the Concrete Pad22
- C Caulking Around the Firebox Base22
- D Caulking Around the Outside Perimeter of HEATMOR22
- E Filling the HEATMOR™ Outdoor Furnace Initially with Water23
- F Maintaining Water in the Bladder and in the HEATMOR24
- G Initial Installation of Sand25
  - Types of Sand to Use25
  - Installation25
9 Safe Operating Guidelines26
- A Operation26
- B Lighting Your HEATMOR™ for the First Time28
- C Dew Point29
- D Loading Wood into the HEATMOR30
- E What Can I Burn31
  - Wood31
- F How Does a Fire Burn out31
- G Types of Wood32
- H Wood as a Fuel32
- I Stages of Combustion32
- J Efficiency Measurements and Types of Fires33
- K Types of Fires33
- L Handling and Storage of Wood34
- M Types of Coal35
- N Coal as a Fuel35
- O Handling and Storage of Coal35
- P Loading Coal into the HEATMOR35
10 Water36
- A Qualities of Water to Use36
- B Water Level Maintenance36
- C Removal of Water and Replacement of Water36
- D Water Additives37
- E Water Treatment Additives and Safety Specifications38
- F Adding Water Treatment and Freeze Protection Products39
11 Bladder Assembly41
- A Bladder41
- B Bladder Gate Valve and Bladder Hose42
- C Water Level Gauge43
- D Bladder Cover Plate43
12 Water Jacket44
- A Water Jacket44
- B Supply Line and Return Line Connectors44
- C Relief Vent Pipe and Weighted Pop off Ball44
13 Firebox and Other Components45
- A Firebox45
- B Firebox Door46
- C Firebox Door Hoses and Elbows48
- D Firebox Door Handle49
- E Firebox Door Hinge49
- F Firebox Door Latch49
- G Firebox Door Holder50
- H Firebox Door Gasket50
- I Firebox Door Frame51
- J Firebox / Base Connector Clamps52
- K Firebrick52
- L Standard Grates52
- M Optional Shaker Grates53
- N Sand54
  - Types of Sand to Use54
  - Installation54
- O Flash Curtain / Heat Shield55
14 Air Supply56
- A Combustion Air Blower and Flipper Assembly56
  - Operation of the Combustion Air Blower and Flipper Assembly56
  - Steps to Maintain Your Blower / Flipper Assembly56
- B Air Box(S)57
- C Combustion Air Percentage Tube58
- D Automatic Fan Switch (A.F.S.)58
15 Chimney and Top Flue59
- B Chimney Extension(S)59
- A Chimney60
- C Flue60
- D Top Flue Cover60
- E Flue Scraper60
16 Ashes61
- A Ash Management and Ash Removal61
- B Ash Pan62
- C Ash Auger62
- D Ash Auger Tube62
- E Ash Auger Tube Cover Plate63
17 Thermometer (Temperature Gauge)64
18 Electrical65
- A Electrical Supply65
- B Electrical Supply Junction Box65
- C Double Electrical Outlets at Rear66
- D Water Temperature Range Control (Aquastat on the Left)66
- E High Water Temperature Safety Shutoff Controller (Aquastat on the Right)67
- F Front Light and Fan Power Switch68
- G in the Event of a Power Failure69
19 Exterior Cladding and Insulation70
- A Outer Door of HEATMOR70
- B Roof of the HEATMOR70
- C Sides of the HEATMOR71
- D Insulation71
20 Air Leaks72
- A Checking for Air Leaks72
- B Why Do We Not Want any Air Leaks72
21 Water Leaks73
22 Domestic Coil74
23 Season Start up & Shut down Checklists75
24 Frequently Asked Questions78
- Firebox and Other Components79
25 Troubleshooting and Solutions80
- Air Leaks85
- Heatmor™ Stainless Steel Limited Warranty93
- Heatmor™ for Life96
- Notes97

Heatmor 100 CSS - Page 94

Table of Contents

Related product manuals