MAINTENANCE SCHEDULE
Perform the pre-ride inspection (page 41) at each scheduled maintenance period.
I: INSPECT C: CLEAN R: REPLACE A: ADJUST L:LUBRICATE T: TOP UP
E: EMISSION CHECK
Note-15 : Inspect the canister hoses for deterioration, damage or loose connections and canister
for cracks or other damages.
Note-13 : Inspect if side stand switch is installed.
Note-14 : Check CO emission at idle.
Note-9 : Replace drive belt once in every 24000 km.
Note-10 : Replace the front fork oil once in every 2 years or 20000 km, whichever is earlier.
Note-4 : Service more frequently when riding in rain or at full throttle.
Note-8 : Replace the pinion starter assembly once in every 2 years or 21000 km, whichever is earlier.
Note-5 : Replace once in every 12000 km.
Note-6 : Replace engine oil once in every 6000 km. Top up if the oil level is at or near the lower level
mark.
Note-11 : Inspect for any play in the rear suspension mounting bushes, replace if necessary.
Note-12 : Inspect the bearings free play, replace if necessary.
Note-7 : Replace once in every 10000 km or once in a year, whichever is earlier. Replacement requires
mechanical skill.
To be serviced by your Authorised Hero MotoCorp workshop unless the owner
has the relevant tools, technical information and is technically qualified.
*Replace at any point of time, if pre foam and viscous element found damaged.
Note-1 : At higher odometer readings, repeat the frequency interval established here.
The following maintenance schedule specifies all maintenance required to keep your vehicle in peak operating
condition. Maintenance work should be performed in accordance with standards and specifications of Hero
MotoCorp by properly trained and equipped technicians. Your Authorised Hero MotoCorp workshop
meets all of these requirements.
Ensure that each paid service is availed within 90 days or 3000 km from the date of previous service,
whichever is earlier.
Note-2 : Throttle play to be checked and adjusted as per given specification.
In the interest of safety, we recommend that these jobs are carried out only by
your Authorised Hero MotoCorp workshop.
Note-3 : Replace air cleaner element once in every 15000 km or early replacement may be required
when riding in dusty areas.
*At 12000 km inspect if air cleaner element (viscous type) is choked. If found choked, replace
the air cleaner element to keep the engine healthy.
55
To Next Page
Loading...
