IFM Ecomat 300 AC1421 - Page 3

3
ifm Device Manual SmartSPS AC14 with EtherNet/IP interface (AC1421, AC1422), Firmware 3.1.2 2015-11-30
Content
5.2.6 Quick setup: Set the configuration mode .................................................................................... 51
5.2.7 Quick setup: Set the configuration interface ............................................................................... 52
5.2.8 Quick setup: Address the AS-i slaves connected to AS-i master 1 ............................................ 54
5.2.9 Quick setup: Address the AS-i slaves connected to AS-i master 2 ............................................ 55
5.3 AS-i 1 / AS-i 2 .....................................................................................................................56
5.3.1 AS-i 1 / AS-i 2: Master setup ...................................................................................................... 57
5.3.2 AS-i 1 / AS-i 2: Diagnosis ........................................................................................................... 59
5.3.3 AS-i 1 / AS-i 2: AS-i slaves ......................................................................................................... 61
5.4 System ...............................................................................................................................67
5.4.1 System: Programmable Logic Controller (PLC) .......................................................................... 68
5.4.2 System: Information ................................................................................................................... 74
5.4.3 System: Setup ............................................................................................................................ 75
5.4.4 System: Diagnosis ...................................................................................................................... 87
5.5 Interfaces ...........................................................................................................................88
5.5.1 Interfaces: Configuration interface .............................................................................................. 89
5.5.2 Interfaces: EtherNet/IP interface ................................................................................................ 92
5.6 ifm system solutions .........................................................................................................104
5.6.1 Notes on ifm system solutions .................................................................................................. 105
5.6.2 Show information about installed ifm apps ............................................................................... 106
5.6.3 Install single/basic app ............................................................................................................. 107
5.6.4 Install multi app ........................................................................................................................ 108
5.6.5 Update ifm apps ....................................................................................................................... 109
5.6.6 Uninstall ifm apps ..................................................................................................................... 109
6 Setup 110
6.1 Connect the device ..........................................................................................................111
6.1.1 EtherNet/IP interface ................................................................................................................ 111
6.1.2 Configuration interface ............................................................................................................. 111
6.2 Start screen 'Basic settings' .............................................................................................111
6.2.1 Change the basic settings of the device ................................................................................... 112
6.3 Update the firmware of the device ...................................................................................114
6.3.1 Behaviour of the settings upon firmware update ...................................................................... 114
6.3.2 Firmware update from SD card ................................................................................................ 115
6.3.3 Firmware update via the web interface ..................................................................................... 116
6.4 Connect and address AS-i slaves ....................................................................................118
6.5 Setup of EtherNet/IP ........................................................................................................118
6.6 Setup of the configuration interface .................................................................................118
6.7 Exchange AS-i slave ........................................................................................................119
7 Troubleshooting 120
7.1 Status LED .......................................................................................................................121
7.1.1 Status LED: Basic device ......................................................................................................... 121
7.1.2 Status LED: fieldbus EtherNet/IP ............................................................................................. 121
7.2 Online diagnosis function .................................................................................................122
7.2.1 Message types ......................................................................................................................... 122
7.2.2 Locate error sources ................................................................................................................ 122
7.3 Online Support Center (OSC) ..........................................................................................123
7.3.1 OSC: View current error messages .......................................................................................... 124
7.3.2 OSC: Show message history .................................................................................................... 125
8 Appendix 126
8.1 Approval tests / certifications ...........................................................................................127
8.2 Technical data ..................................................................................................................128
8.2.1 Housing .................................................................................................................................... 129
8.2.2 Display elements ...................................................................................................................... 129
8.2.3 Operation .................................................................................................................................. 129
8.2.4 Power supply connections ........................................................................................................ 129
8.2.5 Interfaces .................................................................................................................................. 130