Kioti DK90 - Service as Required

6 -28 DK90
Replace the hoses and clamps.
(See "Checking Radiator Hose and
Clamp" in 200 hours maintenance.)
REPLACING POWER STEER-
ING HOSE
Replace the hoses and clamps.
(See "Checking power steering line" in
200 hours maintenance.)
REPLACING FUEL HOSE
Replace the hoses and clamps.
(See "Checking Fuel line" in 100 hours
maintenance.)
REPLACING INTAKE AIR LINE
Consult your local KIOTI Dealer for this
service.
REPLACING RADIATOR HOSE
(WATER PIPES)
SERVICE AS REQUIRED
STEERING WHEEL
It is difficult to drive straight, if the
steering wheel clearance is not good.
Moderate steering wheell play is
20~50mm(0.8~2.0in)
(1) Steering Wheel
(A) 20 ~ 50mm (0.8 ~ 2.0 in.)
S43O641A
(1) High Pressure Pipe
S43O647A
AIRBLEEDING FUEL SYSTEM
 Do not run the engine before air-
bleeding the fuel injection
pump.
 After bleeding the system, run
the engine for 2 minutes at low
idle
!!
!!
!
CAUTION
If equiped with DELPHI DP210 fuel in-
jection pump, when the ignition key is
turned to "RUN" position and operated
for 3 minutes, air is automatically
purged.