Page 7 of 8
6. Maintenance and storage
For hoist maintenance or storage, comply with the following points.
Care
・
Do not lubricate the friction plate of the mechanical brake.
・
Do not drag or throw the hoist when carrying.
The use of chains other than those supplied by KITO is not permitted.
Wipe off dust and moisture, and apply oil to the neck of hook and the load chain.
Always ensure that oil is applied to the load chain, the chain pin (for LX005), the top pin, the hook necks, the hook latches
and the select lever. Refer to “2.1.1 Schematics.”
Perform all inspections given in “5 Inspection” if irregularity of the hoist is found after operation.
Storage
When not in use, ensure that it does not encumber other works.
Before storing the hoist, rotate the lever counterclockwise several times.
Do not store the hoist under load conditions.
Store the hoist in a dry and clean area.
When installing outdoors, cover the hoist to avoid exposure to rain or store in a place with covering against rain.
7. Warranty
KITO Corporation (referred to after as KITO) extends the following warranty to the original purchaser (referred to after as
Purchaser) of new products manufactured by KITO (KITO’s Products)
KITO warrants that KITO’s Products, when shipped, shall be free from defects in workmanship and/or materials under normal
use and service and KITO shall, at the election of KITO, repair or replace free of charge any parts or items which are proven to
have said defects, provided that all claims for defects under this warranty shall be made in writing immediately upon discovery
and, if there is anything within one(1) year from the date of purchase of KITO’s Products by Purchaser and provided, further,
that defective parts or items shall be kept for examination by KITO or its authorized agents or returned to KITO’s factory or
authorized service center upon request by KITO.
KITO does not warrant components of products provided by other manufacturers. However to the extent possible, KITO will
assign to Purchaser applicable warranties of such other manufacturers.
Except for the repair or replacement mentioned above which is KITO’s sole liability and purchaser’s exclusive remedy under this
warranty, KITO shall not be responsible for any other claims arising out of the purchase and use of KITO’s Products, regardless
of whether Purchaser’s claims are based on breach of contract tort or other theories, including claims for any damages whether
direct, indirect incidental or consequential.
This warranty is conditional upon the installation, maintenance and use of KITO’s Products pursuant to the product manuals
prepared in accordance with content instructions by KITO. This warranty shall not apply to KITO’s Products which have been
subject to negligence, misuse, abuse, misapplication or any improper use or combination or improper fittings, alignment or
maintenance.
KITO shall not be responsible for any loss or damage caused by transportation, prolonged or improper storage or normal wear
and tear of KITO’s Products or for loss of operating time.
This warranty shall not apply to KITO’s Products which have been fitted with or repaired with parts, components or items not
supplied or approved by KITO or which have been modified or altered.
THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES. EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO
ANY WARRANTY OF MERCHANTABILITY OR OF FITNESS FOR A PARTICULAR PURPOSE.
DANGER
WARNING
To Next Page
Loading...
Need help?
General
