KONRAD 560 - User Manual

GENERAL INSTALLATION MANUAL
500 Series Models
KONRAD, INC.
1421 HANLEY ROAD • HUDSON, WI 54016-9376 USA
Phone: 715-386-4203 • Toll Free: 1-800-927-3545 • Fax: 715-386-4219
www.konradmarine.com

Summary

Safety Notices

Torque Specifications for Selected Fasteners

Step 1: Transom Cutout

Step 2: Transom Assembly Installation

Step 3: Oil Reservoir Installation

Step 4: Trim;Lift Pump Installation

Step 5: Stern Drive Installation

Step 6: Alignment Procedures

A) Direct Couple Rear Mount with Tailpiece

B) Direct Rubber Coupling

Step 7: Trim Cylinder Installation

Step 8(a): 520 & 540 Propeller Installation

Step 8(b): 560 Propeller Installation

Step 9: Stern Drive Lubrication

Step 10: Trim;Lift Control Module Installation

Step 11: Trim;Lift Pump Filling;Bleeding Procedure

Step 12: Setting Trim;Lift Limit & Sender Switch

Step 13: Manual Hydraulic Steering System Installation

Step 14: Power Steering System Installation

Step 15: Rubber Coupling Extension Shaft(s) Installation

Step 16: U-Joint Extension Shaft Installation

Step 17: CV Extension Shaft Installation

Step 19: Rear Mount; Tailpiece Installation

Step 20: Installation Review

Installation Checklist-Inside of Vessel

Items to check inside the vessel after stern drive installation.

Installation Checklist-Outside of Vessel

Items to check outside the vessel after stern drive installation.

KONRAD 560 Specifications

General

Brand	KONRAD
Model	560
Category	Outboard Motor
Language	English