Home
Kubota
Lawn Mower
M100GX
Kubota M100GX User Manual
5
of 1
of 1 rating
178 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
147
APPENDICES
B
Information Displayed and its Handling
Selected
screen
Info
Display
Remarks
Ref.
page
A
Travel
speed
Travel speed
A
Shows the standard factory settings. Refer to the
"Handling the side digital display" section.
35
Average travel speed
35
PTO
PTO rpm (Shift 1)
A
Shows the standard factory settings. Refer to the
"Handling the side digital display" section.
66
PTO rpm (Shift 2)
66
Engine
rpm
-
Upper-
limit rpm
setting
47
Memory
A rpm
47
Memory
B rpm
47
168
170
Table of Contents
Default Chapter
4
Safety First
4
Table of Contents
5
Safe Operation
23
Servicing of Tractor
23
Specifications
25
Specification Table
25
Traveling Speeds
27
Implement Limitations
28
Instrument Panel and Controls
30
Pre-Operation Check
35
Daily Check
35
Operating the Engine
36
Exhaust Aftertreatment Devices
36
Diesel Oxidation Catalyst and Diesel Particulate Filter (DPF) Muffler
36
Handling Points
37
DPF Regeneration Process
37
Regeneration Operating Procedure
39
PM Warning Level and Required Procedures
40
Regeneration Operating Procedure
41
PM Warning Level and Required Procedures
42
Tips on DPF Regeneration
43
Starting the Engine
43
Cold Weather Starting
48
Block Heater (if Equipped)
48
Stopping the Engine
48
Warming up
48
Warm-Up and Transmission Oil at Low Temperature Range
48
Jump Starting
49
Operating the Tractor
50
Operating New Tractor
50
Do Not Operate the Tractor at Full Speed for the First 50 Hours
50
Changing Lubricating Oil for New Tractors
50
Boarding and Leaving the Tractor
50
Starting
50
Operator's Seat
50
Seat Belt
52
Instructional Seat
52
Steering Adjustment
53
Extendable Mirror
53
Light Switch
53
Turn Signal / Hazard Light Switch
53
With Trailer Connector
54
Horn Button
54
Work Light Switch (Front)
54
Work Light Switch (Rear)
54
Brake Pedals (Right and Left)
55
Clutch Pedal
56
Power Shift / Range Shift Lever (PS. Lever)
57
DHC Switch
58
Shuttle Lever
59
Creep Lever (if Equipped)
59
4WD / Bi-Speed Turn Switch [4WD Model]
60
Hand Throttle Lever
61
Foot Throttle
61
Rev-Limiter Control Dial
61
Parking Brake Lever
61
Contents
55
Stopping
61
Check During Driving
61
Immediately Stop the Engine if
61
Easy Checker(TM)
62
Fuel Gauge
63
Coolant Temperature Gauge
63
Tachometer
63
Hour / Trip Monitor
63
Side Digital Display
64
Initial Setting
64
Factory-Set Screen Display
66
Electronic Engine Control
69
Rev-Limiter Control Setting
69
RPM Dual Memory Setting
69
Constant RPM Management Control
72
Auto Mode
73
Outline
73
Operation
75
Work Speed Display
76
Changing the Field Speed
77
Sensitivity Adjustment
78
Changing the Auto-Mode Setting
78
Front Suspension
81
Outline
81
Suspension Switch
81
Ride Condition Damper Switch
83
Manual Control Mode
83
Parking
84
Operating Techniques
84
Differential Lock
84
Rear Wheel Differential Lock Pedal
85
Front Wheel Differential Lock Switch
85
Operating the Tractor on a Road
86
Operating on Slopes and Rough Terrain
86
Transport the Tractor Safely
86
Directions for Use of Power Steering
86
Trailer Electrical Outlet
87
Pto
88
Pto Operation
88
PTO Clutch Control Switch
88
PTO Gear Shift Lever
89
PTO Gear Shift Lever
90
PTO Shaft Cover and Shaft Cap
90
Three-Point Hitch & Drawbar
91
3-Point Hitch
92
Selecting the Holes of Lower Links
92
Adjusting Lateral Float
92
Selecting the Top Link Mounting Holes
92
Drawbar
92
Remote Hitch up / down Switch
93
Lifting Rod (Left)
93
Lifting Rod (Right)
93
Top Link
94
Telescopic Stabilizers
94
Quick Hitch (Hook Type)
94
Drawbar
96
Adjusting Drawbar Length
96
Swing Drawbar
96
Hydraulic Unit
97
3-Point Hitch Control System
97
Terminology
97
Mode Selector Switch
98
Position Control Mode
98
Mixed Draft Control Mode
99
Float Control
99
Bottom Limit Control Dial
100
Lift Arm Top Limit Adjustment Dial
100
3-Point Hitch Lowering Speed Adjustment Dial
100
3-Point Hitch Lowering Lock Lever
100
3-P. Quick Raise / Lower Switch
101
3-Point Hitch's Position Lock
102
Remote Hydraulic Control System
102
Remote Control Valve
102
Remote Control Valve Lever
102
Remote Control Valve Coupler Connecting and Disconnecting
103
Adjusting the Flow Rate
103
Remote Couplers Spillage Collector
104
Hydraulic Control Unit Use Reference Chart
105
Tires, Wheels and Ballast
106
Tires
106
Inflation Pressure
106
Dual Tires
106
Wheel Adjustment
107
Front Wheels (with Four Wheel Drive)
107
Adjusting Front Wheel Turning Stopper Bolt
108
Rear Wheels
109
Ballast
110
Front Ballast
110
Contents
111
Rear Ballast
111
Cab Operation
112
Door and Window
112
Locking and Unlocking the Door
112
Opening the Door
112
Rear Window
112
Sun Roof
113
Emergency Exit
113
Dome Light
113
Wiper
113
Front Wiper / Washer Switch
113
Rear Wiper / Washer Switch
114
Using the Wipers in Cold Season
114
Air Conditioner
114
Airflow
114
Air Control Vent
115
Control Panel
115
Operation
116
Installing the Implement Control Box
118
Electrical Outlet
118
Beacon Light
119
Beacon Light Switch
119
Maintenance
120
Service Intervals
120
Lubricants, Fuel and Coolant
124
Periodic Service
126
How to Open the Hood
126
Hood
126
Side Cover
126
Daily Check
126
Walk Around Inspection
127
Checking and Refueling
127
Checking Water Separator
127
Checking Engine Oil Level
128
Checking Transmission Fluid Level
128
Checking Coolant Level
128
Cleaning Evacuator Valve
129
Cleaning Grill, Radiator and Screen
129
Checking DPF Muffler
131
Checking Brake Pedal
131
Checking Gauges, Meter and Easy Checker(TM)
131
Checking Head Light, Turn Signal / Hazard Light Etc
131
Checking Seat Belt
131
Checking Movable Parts
131
Every 50 Hours
132
Checking Engine Start System
132
Checking Wheel Bolt Torque
133
Checking Tie-Rod Dust Cover
133
Every 100 Hours
133
Lubricating Grease Fittings
133
Cleaning Air Cleaner Primary Element
135
Adjusting Fan Belt Tension
136
Checking Fuel Line
136
Adjusting Brake Pedal
137
Adjusting Parking Brake Lever
137
Checking Battery Condition
138
Every 200 Hours
139
Checking Radiator Hose and Clamp
139
Checking Oil Cooler Line
141
Checking Intake Air Line
141
Checking Power Steering Line
141
Adjusting Toe-In
142
Draining Fuel Tank Water
142
Cleaning Inner Air Filter
143
Cleaning Fresh Air Filter
143
Adjusting Air-Conditioner Belt Tension
144
Every 300 Hours
144
Replacing Hydraulic Oil Filter
144
Every 400 Hours
145
Changing Engine Oil
145
Replacing Engine Oil Filter
146
Checking Fan / Air-Conditioner Belt Tension
146
Cleaning Pre-Fuel Filter
148
Replacing Fuel Filter
148
Cleaning Water Separator
148
Cleaning Fuel Solenoid Pump Element
149
Every 600 Hours
150
Changing Transmission Fluid
150
Changing Front Differential Case Oil
151
Changing Front Axle Gear Case Oil
151
Adjusting Front Axle Pivot
152
Adjusting King-Pin Pivot
152
Every 800 Hours
152
Replacing Fuel Filter
152
Adjusting Engine Valve Clearance
152
Every 1500 Hours
152
Cleaning Fuel Injector Nozzle Tip
152
Checking and Cleaning EGR Cooler
152
Checking Accumulator
152
Every 3000 Hours
152
Checking Intake Air Heater
153
Checking and Cleaning EGR System
153
Cleaning DPF Muffler
153
Contents
153
Every 1 Year
153
Replacing Air Cleaner Primary Element and Secondary Element
153
Checking Air-Conditioner Pipe and Hose
153
Checking CAB Isolation Cushion
153
Checking Exhaust Manifold
153
Checking DPF Differential Pressure Sensor Pipe
153
Checking EGR Pipe
153
Anti-Freeze
154
Replacing Radiator Hose (Water Pipes)
155
Replacing Power Steering Hose
155
Replacing Fuel Hose
155
Replacing Oil Cooler Line
155
Replacing Intake Air Line
155
Replacing DPF Differential Pressure Sensor Hose
155
Replacing Boost Sensor Hose
155
Replacing Parking Brake Cable
155
Replacing Brake Hose
155
Replacing Clutch Hose
155
Replacing Master Cylinder Kit
156
Replacing Equalizer Kit
156
Replacing Brake Seal 1 and 2
156
Replacing Lift Cylinder Hose
156
Replacing Air Conditioner Hose
156
Replacing Suspension Hose
156
Service as Required
156
Bleeding Fuel System
156
Bleeding Brake System
157
Draining Clutch Housing Water
157
Replacing Fuse
157
Replacing Slow-Blow Fuses
159
Replacing Light Bulb
160
Replacing Head Lamp
160
Lubricating Points
160
Adding Washer Liquid
161
Checking the Amount of Refrigerant (Gas)
161
Storage
162
Tractor Storage
162
Removing the Tractor from Storage
162
Troubleshooting
163
Engine Troubleshooting
163
Power Shift/Range Shift Trouble Shooting
165
Options
167
Appendices
168
Side Digital Display
168
Changing the Information Displayed
168
Information Displayed and Its Handling
169
Displaying and Using the Work History
172
Measuring the Distance
174
Changing the Units and Dates
174
Index
176
Other manuals for Kubota M100GX
Workshop Manual
21 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Kubota M100GX and is the answer not in the manual?
Ask a question
Kubota M100GX Specifications
General
Brand
Kubota
Model
M100GX
Category
Lawn Mower
Language
English
Related product manuals
Kubota M110GX
178 pages
Kubota M126GX
178 pages
Kubota M135GX
178 pages
Kubota M96SDTM
142 pages
Kubota KGZ770-MA1
117 pages
Kubota M100GX-II
209 pages
Kubota G23
343 pages
Kubota Z411
90 pages
Kubota ZD1211
113 pages
Kubota zd 331
96 pages
Kubota ZD1011
100 pages
Kubota WSM BX2380
436 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
