Page 2
Lotus Service Notes Section OK
RECOMMENDED LUBRICANTS
Engine
In order to ensure the longevity and reliability of the vehicle, it is most important that only the specified
lubricants are used. It is an entirely false economy to try to save money by using lower quality oils, which
may break down before the next change interval and provide inadequate protection before the end of the term.
High oil consumption may also result.
For topping up purposes during the running-in period prior to the First After Sales Service, the recom-
mended lubricant is Havoline Ultra 5W/40 semi-synthetic. If this is unavailable, a top quality semi-synthetic
5W/30 or 5W/40 oil should be used.
At the First After Sales Service and completion of the running-in period, a fully synthetic oil should then
be used throughout the life of the vehicle. A top quality fully synthetic 5W/40, such as 'Havoline Synthetic' is
suitable for all climatic conditions likely to be encountered, and provides ease of cranking, smooth cold running
and fuel economy at low temperatures, in combination with good wear protection at elevated temperatures and
at high engine speeds. Note that no oil additives are approved by Lotus.
Viscosity: ambient above -20°C SAE 5W/40
Quality standard API SL/CF; ACEA A3/B3-04
Capacity: refill inc. filter: 6.1 litre
dry - no heat exchanger 6.8 litre
dry - with heat exchanger 7.1 litre
Difference between high & low dipstick marks 1.0 litre
Oil change interval Refer to Maintenance Schedule
Transmission (gearbox & final drive)
Viscosity SAE 75W/80
Quality standard API GL-4
Approved product Havoline Multigear MTF 75W-80 (semi-synthetic)
Capacity 2.3 litre
Oil change interval Refer to Maintenance Schedule
Brake & Clutch System
Type Non-mineral (non-petroleum) hydraulic fluid
Specification DOT 4
Capacity - inc. brake and clutch systems 580 cc
Fluid change interval 24 months
Power Steering System (PAS)
Fluid type: PAS or Automatic Transmission Fluid (ATF)
Specification: Dexron III
Capacity: 1.5 litres
Fluid change interval: Not routine
Engine Coolant Additive
Approved product Havoline XLC
Type Ethylene glycol antifreeze with OAT corrosion inhibitors
Colour Orange
Quantity reqd. @ 50% concentration 8.5 litres
Coolant change interval 4 years
To Next Page
Loading...
