MacDon M105 User Manual (English)

Other manuals for MacDon M105

Operator's Manual384 pages

Manual52 pages

Assembly Instructions54 pages

Questions and Answers:

D
Dennis EvansSep 9, 2025
How to fix MacDon Tractor when it overheats?
- B
  Brent LeeSep 9, 2025
  If the MacDon Tractor engine overheats, start by checking the coolant level and filling the reserve tank to the proper level, also checking the system for leaks. If water is being used as the only coolant, replace it with antifreeze. Reduce ground speed if the engine is overloaded. Other potential causes include a defective radiator cap (replace it), a defective fan belt (replace it), or a dirty radiator core (clean it).
K
Kristy RaymondAug 25, 2025
Why does my MacDon M105 Farm Equipment lack power?
- C
  Charlene CoxAug 26, 2025
  If your MacDon Farm Equipment engine lacks power, several factors could be responsible. Ensure you are using the recommended oil. Check and service the air cleaner to address any intake air restrictions. Replace the primary fuel filter, and if necessary, replace the secondary fuel filter if it's clogged. High back pressure can also cause power loss, so clean out or replace the muffler. Finally, ensure you are using the proper fuel.
K
Kristy MossAug 27, 2025
What causes slow starter operation in MacDon Farm Equipment?
- B
  Brittany WalkerAug 27, 2025
  If the starter on your MacDon Farm Equipment cranks slowly or won't operate, check the battery charge and clean and tighten any loose or corroded connections. Ensure the controls are in NEUTRAL by moving the GSL to NEUTRAL. Also, check the relay and wire connections, and replace the main fuse if it is defective or blown.
S
Shelby HaleAug 27, 2025
Why does my MacDon M105 engine stall frequently?
- D
  Derrick WilsonAug 27, 2025
  If your MacDon Farm Equipment engine runs irregularly or stalls frequently, it could be due to an unsteady fuel supply. Try changing the filter on the fuel tank vent line and replacing the clogged fuel filter. Water or dirt in the fuel system can also cause this issue, so drain, flush, and fill the fuel system. Additionally, check the thermostat after removing it, and if there is air in the fuel system, contact your dealer.
N
Nancy BrownAug 29, 2025
What causes engine knocking in MacDon Farm Equipment?
- D
  dominic77Aug 29, 2025
  If the engine in your MacDon Farm Equipment knocks, it could be due to insufficient oil, so add oil. Ensure you are using the proper fuel. If the coolant temperature is low or high, contact your dealer.
D
David HorneAug 30, 2025
What to do for low oil pressure in MacDon M105?
- M
  Meagan Dalton DVMAug 30, 2025
  If your MacDon Farm Equipment has low oil pressure, it might be due to a low oil level, so add oil. It could also be caused by using the improper type of oil, so drain and fill the crankcase with the proper oil.
C
Candace RodriguezSep 14, 2025
Why do the air filters on my MacDon Tractor require frequent cleaning?
- P
  Patricia BrownSep 15, 2025
  If the air filters on your MacDon Tractor require frequent cleaning, it could be due to a plugged aspirator, which needs to be cleaned out. Another possible cause is a pre-cleaner rotor not turning freely, which requires repair or replacement.
E
Eric OsborneSep 12, 2025
What does it mean when the warning alarm sounds on my MacDon Tractor?
- K
  Katherine WilsonSep 12, 2025
  If you hear a warning alarm sounding on your MacDon Tractor, it could be due to the engine overheating, so check the coolant level. It might also be caused by low engine oil pressure, so check the oil level.
B
Bradley JohnsonSep 8, 2025
What to do if MacDon Tractor starter cranks slowly or will not operate?
- B
  Brenda DanielSep 8, 2025
  If the starter on your MacDon Tractor cranks slowly or won't operate, check the battery charge, and ensure the controls are in NEUTRAL by moving the GSL to NEUTRAL. Also, inspect for loose or corroded battery connections, and clean and tighten them if necessary. High crankcase oil viscosity can also cause this issue, so use the recommended oil. Check the main fuse and key power fuse, replacing them if they are defective or blown. In case of a worn key switch or loose terminals, contact your Dealer. If the switch at the interlock is not closed or is defective, adjust or replace it.
A
Amanda ShahSep 5, 2025
What to do if MacDon Tractor engine runs irregularly or stalls frequently?
- J
  Jose ThomasSep 6, 2025
  If the MacDon Tractor engine runs irregularly or stalls frequently, the issue might stem from an unsteady fuel supply. Try changing the filter on the fuel tank vent line and replacing the clogged fuel filter. Another potential cause is water or dirt in the fuel system, which requires draining, flushing, and refilling the system. Low coolant temperature can also lead to these problems, so it's advisable to remove and check the thermostat. If the injectors are dirty or faulty, contact your Dealer.

MacDon M105 Specifications

General

Header Type	Draper
Cutting Width	Varies with header
Weight	Varies with configuration
Reel Speed	Variable
Transport Width	4.27 m
Required Horsepower	160 hp (119 kW)