MacDon M105 - User Manual

Other manuals for MacDon M105

Assembly Instructions54 pages

Unloading And Assembly Instructions53 pages

Manual52 pages

Questions and Answers

M
Mary CooperNov 21, 2025
How to troubleshoot engine starting problems in MacDon Farm Equipment?
- K
  kimberly47Nov 21, 2025
  If your MacDon Farm Equipment engine is hard to start or won't start, several factors could be at play. First, ensure the controls are in NEUTRAL by moving the GSL to NEUTRAL, locking the steering wheel, and disengaging the header drive switch. Check the fuel supply—fill the tank if empty or replace a clogged filter. Old fuel can also be a culprit, so drain the tank and refill with fresh fuel. Additionally, water, dirt, or air in the fuel system can cause issues; drain, flush, fill, and prime the system to resolve this. Using the improper fuel or crankcase oil that is too heavy can also prevent starting, so use the recommended type. Finally, check the battery; have it tested, ensure the electrolyte level is correct, and clean any loose connections. Wiring shorts or an open circuit breaker,...
K
Kristy RaymondAug 25, 2025
Why does my MacDon M105 Farm Equipment lack power?
- C
  Charlene CoxAug 26, 2025
  If your MacDon Farm Equipment engine lacks power, several factors could be responsible. Ensure you are using the recommended oil. Check and service the air cleaner to address any intake air restrictions. Replace the primary fuel filter, and if necessary, replace the secondary fuel filter if it's clogged. High back pressure can also cause power loss, so clean out or replace the muffler. Finally, ensure you are using the proper fuel.
K
Kristy MossAug 27, 2025
What causes slow starter operation in MacDon Farm Equipment?
- B
  Brittany WalkerAug 27, 2025
  If the starter on your MacDon Farm Equipment cranks slowly or won't operate, check the battery charge and clean and tighten any loose or corroded connections. Ensure the controls are in NEUTRAL by moving the GSL to NEUTRAL. Also, check the relay and wire connections, and replace the main fuse if it is defective or blown.
S
Shelby HaleAug 27, 2025
Why does my MacDon M105 engine stall frequently?
- D
  Derrick WilsonAug 27, 2025
  If your MacDon Farm Equipment engine runs irregularly or stalls frequently, it could be due to an unsteady fuel supply. Try changing the filter on the fuel tank vent line and replacing the clogged fuel filter. Water or dirt in the fuel system can also cause this issue, so drain, flush, and fill the fuel system. Additionally, check the thermostat after removing it, and if there is air in the fuel system, contact your dealer.
N
Nancy BrownAug 29, 2025
What causes engine knocking in MacDon Farm Equipment?
- D
  dominic77Aug 29, 2025
  If the engine in your MacDon Farm Equipment knocks, it could be due to insufficient oil, so add oil. Ensure you are using the proper fuel. If the coolant temperature is low or high, contact your dealer.
J
Jeffery WhiteSep 19, 2025
Why does the header or reel lift but lack power on my MacDon Tractor?
- B
  Brandon HoSep 22, 2025
  If the header or reel lifts but lacks power on your MacDon Tractor, the relief pressure may be too low, or there could be a contaminant in the relief valve. Check, adjust, and clean the relief valve at the cylinder control valve.
A
allison01Sep 16, 2025
What to do if the lights do not light on my MacDon Tractor?
- M
  Molly AndersonSep 16, 2025
  If the lights on your MacDon Tractor do not light, start by replacing the light bulb if it's burned out. Check the wiring for broken wires or shorts. Also, ensure there's a good ground on the lights by cleaning and tightening the ground wires. Finally, check the circuit breaker for any openings or defects.
J
Jeffrey OchoaSep 18, 2025
What causes the header or reel to not lift on a MacDon Tractor?
- E
  Elizabeth AllisonSep 18, 2025
  If the header or reel is not lifting on your MacDon Tractor, there might be a contaminant in the relief valve. Clean the relief valve at the cylinder control valve.
B
Bradley JohnsonSep 8, 2025
What to do if MacDon Tractor starter cranks slowly or will not operate?
- B
  Brenda DanielSep 8, 2025
  If the starter on your MacDon Tractor cranks slowly or won't operate, check the battery charge, and ensure the controls are in NEUTRAL by moving the GSL to NEUTRAL. Also, inspect for loose or corroded battery connections, and clean and tighten them if necessary. High crankcase oil viscosity can also cause this issue, so use the recommended oil. Check the main fuse and key power fuse, replacing them if they are defective or blown. In case of a worn key switch or loose terminals, contact your Dealer. If the switch at the interlock is not closed or is defective, adjust or replace it.
A
Amanda ShahSep 5, 2025
What to do if MacDon Tractor engine runs irregularly or stalls frequently?
- J
  Jose ThomasSep 6, 2025
  If the MacDon Tractor engine runs irregularly or stalls frequently, the issue might stem from an unsteady fuel supply. Try changing the filter on the fuel tank vent line and replacing the clogged fuel filter. Another potential cause is water or dirt in the fuel system, which requires draining, flushing, and refilling the system. Low coolant temperature can also lead to these problems, so it's advisable to remove and check the thermostat. If the injectors are dirty or faulty, contact your Dealer.

MacDon M105 Specifications

General

Header Type	Draper
Cutting Width	Varies with header
Weight	Varies with configuration
Reel Speed	Variable
Transport Width	4.27 m
Required Horsepower	160 hp (119 kW)