Mack E7 - Page 301

INDEX
Page 11-5
RING INSTALLATION . . . . . . . . . . . . . . . . . 5-17
ROCKER ARM, VALVE YOKE AND
PUSH ROD . . . . . . . . . . . . . . . . . . . . . . . 4-14
ROCKER ARMS, INSTALLATION . . . . . . . . 6-59
ROCKER ARMS, SERVICE . . . . . . . . . . . . . 5-47
RUN-IN CHECK . . . . . . . . . . . . . . . . . . . . . . . 8-5
S
SAFETY INFORMATION . . . . . . . . . . . . . . . . . iii
SETTING STATIC FUEL INJECTION
PUMP TIMING . . . . . . . . . . . . . . . . . . . . . 7-13
SETUP AND ADJUSTMENTS . . . . . . . . . . . . 7-1
SLAVE PISTON ADJUSTMENT . . . . . . . . . 7-10
SLAVE PISTON, INLET VALVE AND
EXHAUST VALVE LASH
ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . 7-9
SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . 2-1
T
THERMOSTAT, THERMOSTAT
HOUSING, THERMOSTAT SEAL AND
COOLANT CONDITIONER . . . . . . . . . . . 6-73
THERMOSTAT . . . . . . . . . . . . . . . . . . . . . . . 4-8
TIMING EVENT MARKER (TEM)
INSTALLATION . . . . . . . . . . . . . . . . . . . . 7-20
TIMING GEAR COVER, INSTALLATION. . . 6-44
TIMING GEAR COVER, REMOVAL. . . . . . . 4-23
TIMING GEAR COVER SEAL . . . . . . . . . . . 6-45
TORQUE SPECIFICATIONS FOR
CRITICAL FASTENERS . . . . . . . . . . . . . . 2-7
TORQUE SPECIFICATIONS FOR
HOSE CLAMPS . . . . . . . . . . . . . . . . . . . . 2-10
TORQUE SPECIFICATIONS FOR
NON-CRITICAL FASTENERS . . . . . . . . . 2-11
TORQUE SPECIFICATIONS FOR PIPE
PLUGS . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-11
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . 9-1
TURBOCHARGER, INSTALLATION . . . . . . 6-72
TURBOCHARGER, REMOVAL . . . . . . . . . . 4-11
V
VALVE COVER . . . . . . . . . . . . . . . . . . . . . . 6-61
VALVE COVER AND RISER . . . . . . . . . . . 4-13
VALVE GUIDES . . . . . . . . . . . . . . . . . . . . . 5-30
VALVE IDENTIFICATION . . . . . . . . . . . . . . 5-43
VALVE LIFTER PUSH RODS . . . . . . . . . . . 6-57
VALVE ROCKER ARM SHAFT . . . . . . . . . . 5-47
VALVE ROCKER ARM SHAFT
ASSEMBLY (EXCEPT JACOBS
ENGINE BRAKE) . . . . . . . . . . . . . . . . . . 5-47
VALVE ROCKER ARM SHAFT ASSEMBLY
(WITH JACOBS ENGINE BRAKE) . . . . . 5-49
VALVE SPRINGS . . . . . . . . . . . . . . . . . . . . 5-38
VALVE YOKE AND VALVE LASH
ADJUSTMENTS (NON-JAKE BRAKE
ENGINE AND DYNATARD
EQUIPPED) . . . . . . . . . . . . . . . . . . . . . . . . 7-2
VALVE YOKE GUIDE PINS . . . . . . . . . . . . 5-39
VALVE YOKES, INSTALLATION. . . . . . . . . 6-58
VALVE YOKE, VALVE LASH AND SLAVE
PISTON ADJUSTMENTS (JACOBS
BRAKE ENGINE) . . . . . . . . . . . . . . . . . . . 7-6
VEHICLE PREPARATION . . . . . . . . . . . . . . 3-2
VIBRATION DAMPER . . . . . . . . . . . . . . . . . 6-46
VIBRATION DAMPER AND
CRANKSHAFT HUB . . . . . . . . . . . . . . . . 4-17
V-MAC EQUIPPED ENGINES . . . . . . . . . . 4-20
V-MAC TOOLS . . . . . . . . . . . . . . . . . . . . . . 2-24
W
WATER PUMP, DESCRIPTION
AND OPERATION . . . . . . . . . . . . . . . . . . 5-57
WATER PUMP, INSTALLATION . . . . . . . . . 6-76
WATER PUMP, REMOVAL . . . . . . . . . . . . . 4-11
WEAR RING WITH DOUBLE-LIP
TEFLON SEAL (AUTOMATIC
TRANSMISSION) . . . . . . . . . . . . . . . . . . 6-32
WRIST PIN REPAIR . . . . . . . . . . . . . . . . . . . 5-7
INDEX.FR5 Page 5 Friday, March 17, 2006 11:04 AM