Mahindra Maxximo Mini Van Vx 2012 - Page 114

Diagnostic Manual MAN-00183
MAXXIMO MINIVAN VX June 2012/Rev 1
The reproduction, translation, transmission, in part of or whole of the present document are prohibited without the prior written consent of Mahindra & Mahindra Ltd. The use of this document by any
person other than the trained personnel, at the Authorized Service Centre of Mahindra & Mahindra Ltd., will amount to unauthorized use and shall be liable for penalty/prosecution. © 2012 Mahindra &
Mahindra Ltd.
114
Ste
p
2
 Clear the error codes and
verify
 Check the 15Amps fuse of the
pre supply pump
 Ignition OFF
 Replace the
fuse
 Clear error
codes and
verify
N
O
YES
Go to Step 3
Is the fuse
Oka
y
?
Is the voltage
12Volts?
Go to Step 8
 Connect the smart tester
 Turn the ignition ON
 Initialize the diagnostic tool
 Record the error codes and clear
 Turn ignition OFF
 Turn ignition ON
 Verify if P0163F,P0163E,
P163D or P1640 is present
Is P0163F, P0163E,
P0163D or P1640
present?
YES
NO
 Turn ignition ON
 Pre supply pump relay connector
DISCONNECTED
 Check the voltage between
pin 30 of the pre supply pump
relay connector and battery
negative and pin 86 of pre
supply pump relay connector
and battery negative
Step 1
YES
NO