Mahindra USA, Inc. All Rights Reserved.
27-1
27 Troubleshooting
Troubleshooting Table
Possible Causes Solution
Engine Doesn't Turn Over
Low battery voltage Recharge the battery
Loose battery connections Check battery connections,
clean and tighten
Loose starter solenoid
connection
Check starter connections,
clean and tighten
Loose fuse box connections or
blown fuse
Remove, inspect and reinstall
related fuses
Engine Turns Over, Fails to Start
Out of fuel Refuel
Clogged fuel filter/water
separator
Drain water separator, inspect
and/or replace fuel filter
Clogged air filter Inspect and/or replace air filter
Water is present in fuel Drain the fuel system and
refuel, replace fuel filter/water
separator
Old or non-recommended fuel Replace with fresh
recommended fuel
Water or fuel in crankcase See your local ROXOR dealer
for assistance
Troubleshooting Table
Possible Causes Solution
Low battery voltage Recharge the battery
Mechanical failure See your local ROXOR dealer
for assistance
Defective fuel pump Inspect and/or replace
Engine Runs Irregularly, Stalls or Misfires
Poor or incorrect fuel Replace with recommended
fuel
Low fuel level Refuel
Clogged fuel filter Inspect and/or replace fuel
filter
Clogged air filter Inspect and/or replace air filter
Water present in fuel
Drain water separator, inspect
and/or replace fuel filter
Kinked or plugged fuel tank
vent line
Inspect and/or replace
Other mechanical failure See your local ROXOR dealer
for assistance
Engine Stops or Loses Power
Poor or incorrect fuel Replace with recommended
fuel
Air leak in system after
turbocharger
Inspect for leaks and repair as
required
Troubleshooting
To Next Page
Loading...
Need help?
General
