Masterbuilt 7BCM User Manual

17
6
BURNER MAINTENANCE
CCaasstt IIrroonn BBuurrnneerr FFllaammee iiss YYeellllooww oorr NNoo FFllaammee??
If burner flame is yellow, blows out frequently, does not light or flame is inside venturi then burner venturi needs to
be checked for obstructions. Dirt dobbers, spiders and other insects build nests inside burner venturi blocking air
and gas flow. KEEP AIR SHUTTER CLOSED AFTER EACH USE.
HHooww ttoo cclleeaann bbuurrnneerr aasssseemmbbllyy::
1. Remove hose from burner using adjustable wrench.
2. Insert small rod in opening of burner where hose was attached. This
should breakup any obstructions.
3. Hold burner up to light and look for other obstructions.
4. If burner has not been cleared then flush with water. Make sure burner is completely dry before using.
5. Once burner has been cleared reassemble burner.
KKEEEEPP BBUURRNNEERR VVEENNTTUURRII FFRREEEE OOFF OOBBSSTTRRUUCCTTIIOONNSS
OORR DDAAMMAAGGEE TTOO HHOOSSEE AASSSSEEMMBBLLYY MMAAYY OOCCCCUURR..
CCooookkiinngg iinn CCoooolleerr//HHiigghheerr CClliimmaatte
ess
When outside temperature is cooler than 65°F (18°C) and/or altitude is above 3,500 feet (1067m), additional cooking
time may be required. To insure that meat is completely cooked use a meat thermometer to test internal
temperature.
LLiiffttiinngg SSmmookkeerr LLiidd
during cooking process may extend cooking time due to heat loss.
UUssiinngg OOnnee GGrriillll RRaacckk
When using only one grill rack, use upper grill rack for better results.
UUssiinngg TTwwoo GGrriillll RRaacckkss
When using both grill racks, place food requiring least cooking time on top grill rack.
COOKING TIPS AND WOOD SMOKING GUIDE
WOOD FLAVOR POULTRY FISH HAM BEEF PORK LAMB
Hickory
Pungent, smoky, bacon-like flavor
9 9 9 9 9
Mesquite
Sweet and delicate flavor
9 9 9
Alder
Delicate, wood smoke flavor
9 9 9
Pecan
Bold and hearty flavor
9 9 9
Maple
Sweet, subtle flavor
9 9
Apple
Sweet, delicate flavor
9 9 9
Cherry
Sweet, delicate flavor
9 9
WOOD SMOKING GUIDE FOR MEATS
PPLLAACCEEMMEENNTT OOFF AAPPPPLLIIAANNCCEE FFOORR SSAAFFEETTYY
BBeeffoorree uussiinngg ssmmookkeerr cchheecckk wwiinndd ddiirreeccttiioonn && ppllaaccee ccyylliinnddeerr UUPPWWIINNDD,, uupprriigghhtt 1122”” ((3300..55ccmm)) aawwaayy ffrroomm uunniitt..
10 feet
Wind Flow
10 feet
Wall
Rails
Overhead Construction
WARNING
Perform “Soapy Water Test” before each use. See “Soapy Water Test” section in manual.
Extinguish all open flames before connecting regulator to gas cylinder.
Turn gas OFF after each use.
BBUURRNNEERR
LLIIGGHHTTIINNGG IINNSSTTRRUUCCTTIIOONNSS
CLOCKWISE
COUNTER
CLOCKWISE
• Check regulator control valve to be certain it is in OFF position
before connecting gas cylinder.
• Perform Soapy Water Test.
• Turn gas cylinder valve ON. Place lit match to burner under
the wind shield.
• Slowly turn ON regulator control valve until burner lights.
If burner does not light within 5 seconds or is blown out , turn
OFF regulator control valve and then turn gas cylinder valve
OFF. Wait 5 minutes for fumes to diminish before relighting.
• After burner is lit, open regulator control valve until flame
increases.
• Use air shutter on burner to adjust flame until it burns blue.
• Reduce flame.
• After each use turn regulator control valve OFF, then turn gas
cylinder OFF. Always allow cooker stand and cooking vessel
to cool completely to touch before moving or storing.
Regulator Control Valve
Lighting Position
Windshield
Air Shutter
1. Never leave appliance unattended. Even when burner is set to a low flame. Oil will heat up
quickly and ignite at 550°-700° F (288°-371°C).
2. Tripping over appliance hose may result in the spilling of HOT oil or water causing personal
injury and property damage.
WARNING
12” (30.5cm) Apart

Masterbuilt 7BCM Specifications

General

Brand	Masterbuilt
Model	7BCM
Category	Grill
Language	English