McConnel Multidrive M380-4

To Next Page

To Previous Page

McCONNEL MULTIDRIVEM380‐4&M420‐4

MULTIDRIVE

M380-4 & M420-4

All Terrain Carrier Vehicle

OPERATOR INSTRUCTION MANUAL

McCONNEL LIMITED

Temeside Works

Ludlow

Shropshire

England

Telephone: 01584 873131

www.mcconnel.com

Main Page

Default Chapter4
- Table of Contents4
Warranty Policy8
Declaration of Conformity11
Recognised Safety Information12
- Operators Cab13
- Brakes13
- Electrical14
- Steering14
- Spraying19
Safety Decals20
Operation24
Vehicle Controls25
- Cab Controls25
  - Right Hand Side Console25
  - Controls & Switches26
- Stalk Mounted Controls27
Mirror Adjustment43
Seat Adjustment43
- Weight Adjustment43
- Back-Rest Angle Adjustment43
- Armrest Adjustment43
- Fore and Aft Adjustment43
- Seat Cushion Adjustment43
Steering Column Adjustment43
Steering Modes44
- Wheel Steer 'Road Mode45
- Wheel Steer45
- Wheel Steer Delay45
- Crab Steer45
  - Offsets Steering46
Electronic Climate System47
- Cab Ventilation49
General Operation of Vehicle50
- Cruise Control53
Vehicle Equipment56
Power Take off (P.T.O)56
- Single PTO Powersaver Pump56
- PTO Speed Setting56
- Remote PTO Switch57
  - PTO Speed Setup - Centrifugal Pump58
PTO Safety Information59
Ancillary Equipment60
Hydraulic Service Valves61
Optional Equipment62
- Hydraulic Pickup Hitch62
- Single Line Hydraulic Trailer Brake63
- Air Trailer Braking63
Engine Warning & Aftertreatment64
Maintenance and Servicing70
Access to Engine and Radiator70
Engine Air Cleaner71
Screen Wash Reservoir72
Electrical System72
- Isolator Switch73
- Checking Batteries73
- Distribution Board Layout74
- Fuse Box Layout75
Foot Brake Adjustment77
- Powerbrake Operation Check77
- Park Brake77
Air System79
- Maintenance and Operation of Air Brake System80
- Compressor80
- Air Reservoir80
- Hose Coupling80
  - Weekly Maintenance80
Air Suspension81
Cab - Composite Air Filter82
- Installation82
- Maintenance82
- Changing the Filter82
- Cab Air Filters82
Lubrication and Periodic Service83
- Daily/Every 10 Hours83
- First 100 Hours of Operation85
- After First 100 Hours85
- Every 250 Hours86
- Every 500 Hours87
- Every 1000 / 2000 Hours88
- Transmission88
  - Lubrication Schedule Check Sheet89
Capacities90
- Engine91
Recommended Lubricants Fuel Coolant and Service91
- Fuel91
- Fuel Filters92
  - Lubrication Oil93
- Def94
- Coolant95
  - Hydraulic Tank95
  - Transmission Lubrication and Maintenance96
- Oil Grade96
Axle and Propshaft Lubrication103
Set-Up Procedure of Axle Stops105
- Front Axle105
- Rear Axle105
Wheel Track Settings106
Wheel Steering Calibration107
Axle & Wheel Specification Details110
- Wide Floatation Tyres110
- Tyre Data111
Vehicle Identification115
- Serial Numbers115
- Type Plates115
Mounting Instructions117

McConnel Multidrive M380-4 - Page 2

Table of Contents