McCONNEL MULTIDRIVEM380‐4&M420‐4
80
Service and Warranty
Refer to Warranty Policy at the front of this manual.
Warranty does not cover faults caused by incorrect use and servicing or faults caused by
fertiliser or chemical corrosion.
All servicing should be carried out as per this instruction manual particularly during the
warranty period. The first service is normally carried out by the customer after the first
hundred hours running. If any faults are apparent on delivery, at this first service or during
the warranty period McConnel Limited would appreciate notification as soon as possible,
even if the fault is rectified by the customer. McConnel understand that many customers
will repair straight-forward faults themselves without reporting them, however McConnel
policy is one of continual improvement and with co-operation and any suggestions and
ideas, product enhancements can be made to the mutual advantage of customer and
supplier.
If any problems occur with the machine please contact McConnel Limited, without delay,
with whom you can discuss the best way to deal with the problem to avoid unnecessary
delays. If a repair is carried out by the customer or by an outside engineer to save time,
and it is wished to claim costs under warranty, McConnel Limited must be notified first or
the claim will not be accepted under any circumstances. Unauthorised repairs may affect
or even invalidate any remaining warranty. Any parts replaced must be returned to us for
assessment.
If McConnel service engineers are called out at any time, to work on the machine or if the
machine has to be returned to their works for repair, it must be thoroughly cleaned to
remove all chemical and fertiliser residues to enable the work to be carried out safely and
effectively. If the machine is not clean, the right is reserved to either refuse to carry out the
work or to charge for cleaning.
Maintenance, Technical Information, Lubrication and Periodic Service
DAILY / EVERY 10 HOURS
Component Description
Engine Crankcase Check oil level.
Engine Crankcase Breather Tube Check
Primary Fuel Filter Check filter/ water bowl drain as
required.
Radiator & Cooling Fan Check coolant level
Check to ensure the grill is free from
debris and that no debris and bypassed
the grill and is blocking the cooling
pack
Check the cooling fan
Air Intake System Check air cleaner restriction
Check air intake piping
Air Cleaner Valve Clean out dust as necessary
To Next Page
Loading...