Mec Micro 26 - Page 18

Page 14 Micro 26 - Operator’s Manual
March 2019Section 7 - Operating Instructions and Function Tests
Functions Tests
Select a test area that is indoors firm, level and free of obstruction.
Be sure the battery pack is connected.
Turn the main power switch to ON (pulled out) position.
At the Ground Controls
ART_5015
Pull or turn the red Emergency Stop button clockwise to the on position at
both the ground and platform controls.
Turn the Key Switch to ground control.
Observe the diagnostic LED readout on the ECU window located at the
Platform Controls.
Result: The LED should look similar to the picture below.
1.
2.
3.
•
Test Emergency Stop
Push in the ground red Emergency Stop button to the off position.
Result: No functions should operate.
Turn the red Emergency Stop button clockwise to the on position.
Test Up/Down Functions
Check the area above and around the machine for obstructions and
electrical power lines before operating the machine.
A buzzer with different sound frequency is controlled by the central system. The descent alarm
sounds at 60 beeps per minute. The alarm that goes off when the machine is not level or is the
pothole guards have not deployed sounds at 150 beeps per minute.
At the Lower Controls station, turn the Key Switch to off or platform position.
At the Lower Controls station, push up and hold the platform up / down switch.
Result: No function should operate.
Turn the Key Switch to ground control position.
At the Lower Controls station, push up and hold the Platform Up switch.
Result: The platform should raise.
Push down and hold the Platform Down switch.
Result: The platform should lower to end. The descent alarm should sound while the
platform is lowering.
Test the Emergency Lowering
ART_5016
Emergency
Lowering
Handle
Activate the up function and raise the platform approximately 2 ft / 60 cm.
Pull the Emergency Lowering Handle.
Result: The platform should lower. The descent alarm will not sound.
1.
2.
•
At the Platform Controls
Turn the Key Switch to platform control.
1.
2.
3.
1.
•
2.
1.
2.
•
3.
4.
•
5.
•
1.