Midtronics Inc. 7000 Monroe Street Willowbrook, IL 60527
www.midtronics.com
5
General Safety PrecautionsToyota/Lexus DCA-8000
IMPORTANT SAFETY INSTRUCTIONS. WORKING IN
THE VICINITY OF A LEAD-ACID BATTERY IS DANGEROUS.
BATTERIES GENERATE EXPLOSIVE GASES DURING NORMAL
BATTERY OPERATION. FOR THIS REASON, IT IS OF THE UTMOST
IMPORTANCE THAT THESE INSTRUCTIONS ARE FOLLOWED
EACH TME THE CHARGER IS USED.
For safe, ecient, and accurate charging and testing, review
the safety and operating instructions in this manual before
using the analyzer. In addition, follow all manufacturers’
instructions and BCI (Battery Council International) safety
recommendations.
1 General Safety Precautions
Charging a non-rechargeable battery
may cause the battery to burst.
To reduce the risk of injury, only charge re-
chargeable lead-acid type batteries including
maintenance-free, low-maintenance, or deep-
cycle batteries.
Risk of explosive gases.
Batteries generate explosive gases during normal opera-
tion, and when discharged or charged.
1.1
To reduce risk of battery explosion, follow these safety in-
structions and those published by the battery manufacturer
and the manufacturer of any equipment you intend to use
in the vicinity of a battery. Review cautionary markings on
these products and on the engine, and on the vehicle or
equipment containing the battery.
If you are uncertain as to the type of battery you are
attempting to charge, or the correct procedure for
checking the battery’s state of charge, contact the seller
or battery manufacturer.
1.2 Use of an attachment not recommended or sold by the
battery charger manufacturer may result in a risk of re,
electric shock, or injury to persons.
1.3
To reduce risk of damage to the electric plug and cord, pull
by the plug rather than by the cord when disconnecting
the charger.
1.4 Position the AC and DC leads to avoid tripping over them
and to prevent damage from moving engine parts; pro-
tect from heat, oil, and sharp edges.
1.5 Do not operate the charger if it has received a sharp blow,
been dropped or otherwise damaged in any way; take it
to a qualied service center.
1.6 Do not disassemble charger; take it to a qualied service
center when repair is required. Incorrect reassembly may
result in a risk of electric shock or re.
1.7 To reduce risk of electric shock, unplug the charger from
the AC outlet before attempting any maintenance or
cleaning. Turning o the controls will not reduce this risk.
1.8
Connect and disconnect the battery leads only when the
AC supply cord is disconnected.
1.9
Do not overcharge the battery.
1.10
Charge the battery in a dry, well-ventilated area.
1.11
Never place articles on or around the charger, or locate
the charger in a way that will restrict the ow of cooling air
through the cabinet.
1.12
An extension cord should not be used unless absolutely
necessary. (See paragraph 4.2)
1.13
Have a damaged cord or plug replaced immediately.
1.14
Do not expose the charger to rain or snow.
2 Personal Precautions
2.1 This charger is not to be used by people with reduced
physical, sensory or mental capabilities, or lack of experi-
ence and knowledge, unless they have been given super-
vision or instruction.
2.2 Children should be supervised to ensure they do not play
with the equipment.
2.3 Always have someone within range of your voice, or close
enough to come to your aid, when working around lead
acid batteries.
2.4 Have plenty of fresh water and soap nearby in case battery
acid contacts skin, clothing or eyes.
2.5 Wear complete eye protection, clothing protection, and
wear rubber soled shoes. Place damp cloth over battery
to protect against acid spray. When ground is very wet or
covered with snow, wear rubber boots. Avoid touching
eyes while working near battery.
2.6 If battery acid contacts skin or clothing, wash immediately
with soap and water. If acid enters the eye, immediately
ush with cold running water for at least 10 minutes, and
seek medical attention.
2.7 NEVER smoke or allow a spark or ame in vicinity of a bat-
tery or engine.
2.8 Be extra cautious to reduce risk of dropping a metal tool
onto the battery. It might spark or short circuit the battery
or other electrical part that may cause an explosion.
General Safety Precautions
To Next Page
Loading...
Need help?
General
