Mitsubishi PAJERO IV - Page 28

PERIODIC INSPECTION AND MAINTENANCE SCHEDULE
PERIODIC INSPECTION AND MAINTENANCE
2-4
A12 Replace air cleaner element Replace Norma
l usage
Every 40,000 km or every 2
years
Severe
usage
More frequently
A13 Check fluid level in brake reservoir Inspection First 1,000 km, thereafter every
10,000 km or every 6 months
A14 Check fluid level in clutch reservoir (for
hydraulic type clutch only)
Inspection First 1,000 km
A15 Change brake fluid Change Every 40,000 km or every 2 years
A16 Check battery electrolyte level Inspection First 1,000 km, thereafter every
10,000 km or every 6 months
A17 Check injection nozzle [If dark smoke is
exhausted or engine power is low]
Inspection Every 50,000 km or every 2.5 years
A18 Replace fuel filter Petrol-powered
vehicles
Replace Every 60,000 km or every 3 years
Diesel-powered
vehicles
Replace Every 20,000 km or every 12 months
OPERATIONS UNDER THE VEHICLE
B1 Check suspension system for damage and
looseness
Inspection First 1,000 km, thereafter every
20,000 km or every 12 months
B2 Check suspension arm ball joints for play, and
dust covers for damage
Inspection Every 20,000 km or every 12 months
B3 Lubricate propeller shaft with grease fitting Lubrication Every 20,000 km or every 12 months
B4 Check driveshaft boots for damage Inspection Norma
l usage
Every 20,000 km or every 12
months
Severe
usage
First 1,000 km, thereafter
every 10,000 km or every 6
months
B5 Check steering linkage for damage and loose
connections (including seals and boots)
Inspection Every 20,000 km or every 12 months
B6 Check gear oil level in manual transmission Inspection Every 20,000 km or every 12 months
B7 Check gear oil level in transfer case (4WD) Inspection Every 20,000 km or every 12 months
B8 Change gear oil in manual transmission Change Norma
l usage
Every 100,000 km or every 5
years
Severe
usage
Every 40,000 km or every 2
years
B9 Change gear oil in transfer case (4WD) Change Norma
l usage
Every 100,000 km or every 5
years
Severe
usage
Every 40,000 km or every 2
years
B10 Check gear oil level in front and rear
differential
Inspection Every 20,000 km or every 12 months
Maintenance item Maintenance
operation
Maintenance interval