Moffat E31 - 6. Service Procedures; 6 Service Procedures

-17-
Revision 2/F3506
SECTION PAGE NO.
6.1 FAULT DIAGNOSIS ............................................................................................................. 19
6.1.1 Oven Does Not Operate / Start ........................................................................... 19
6.1.2 Fan Does Not Operate ........................................................................................ 19
6.1.3 Oven Light Not Illuminating—Door Open ............................................................ 19
6.1.4 Oven Light Not Illuminating—Door Closed ......................................................... 19
6.1.5 No Water Injection / Steam ................................................................................. 19
6.1.6 Continuous Water Out Of Oven Water Nozzle ................................................... 20
6.1.7 60 Minute Timer No Time Up Buzzer .................................................................. 20
6.1.8 60 Minute Timer No Time Up Indicator ............................................................... 20
6.1.9 No Heat ............................................................................................................... 20
6.1.10 No Temperature Control ..................................................................................... 21
6.1.11 Slow Recovery .................................................................................................... 21
6.1.12 Bottom Element Not Working .............................................................................. 21
6.1.13 Top Element Not Working (In Bake Mode—Not Grill / Broil) .............................. 21
6.1.14 No Thermostat Heating Indicator ........................................................................21
6.1.15 Grill Not Working ................................................................................................. 21
6.1.16 Grill Indicator Not Working .................................................................................. 22
6.1.17 Roast Timer (180 Minute) Will Not Time Down ................................................... 22
6.1.18 No Hold Indicator ................................................................................................. 22
6.1.19 Holding Temperature Incorrect ........................................................................... 22
6.2 ACCESS ............................................................................................................................... 23
6.2.1 Control Panel ....................................................................................................... 23
6.2.2 Service Panel (Rear Panel) ................................................................................. 23
6.2.3 Baffle ................................................................................................................... 23
6.2.4 Control Panel (Rear) ........................................................................................... 23
6.3 REPLACEMENT ................................................................................................................... 24
6.3.1 Light Bulb / Glass ................................................................................................ 24
6.3.2 Door Microswitch ................................................................................................. 24
6.3.3 Indicator Neon Light ............................................................................................ 24
6.3.4 Power / Roast / Lights / Water Switches ............................................................. 24
6.3.5 Buzzer ................................................................................................................. 24
6.3.6 Bake Timer .......................................................................................................... 25
6.3.7 Roast Timer ......................................................................................................... 25
6.3.8 Thermostat .......................................................................................................... 25
6.3.9 Hold Thermostat .................................................................................................. 26
6.3.10 Mini-Contactor ..................................................................................................... 26
6.3.11 Water Solenoid .................................................................................................... 26
6.3.12 Water Solenoid Cleaning ..................................................................................... 27
6.3.13 Spray Nozzle ....................................................................................................... 27
6.3.14 Elements .............................................................................................................. 27
WARNING: ENSURE POWER SUPPLY IS SWITCHED OFF BEFORE SERVICING.
6. SERVICE PROCEDURES
WARNING: ALL INSTALLATION AND SERVICE REPAIR WORK MUST BE CARRIED
OUT BY QUALIFIED PERSONS ONLY.