EasyManua.ls Logo

Napoleon GSS42CFN - User Manual

Napoleon GSS42CFN
48 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
EN
W415-2164 / A / 07.21.16
FR
PG
25
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE.
INSTALLATION AND
OPERATING INSTRUCTIONS
1.39B
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone (705)721-1212 • Fax (705)722-6031 • www.napoleonfi replaces.com • hearth@napoleonproducts.com
SAFETY INFORMATION
!
WARNING
If the information in these instructions are
not followed exactly, a fi re or explosion
may result causing property damage,
personal injury or loss of life.
- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbour’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the
fi re department.
- Installation and service must be performed by a
qualifi ed installer, service agency or the supplier.
CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS.
$10.00
LA VITRE CHAUDE CAUSERA
DES BRÛLURES.
NE PAS TOUCHER LA VITRE
AVANT QU’ELLE AIT REFROIDI.
NE JAMAIS LAISSER LES
ENFANTS TOUCHER LA VITRE.
HOT GLASS WILL CAUSE
BURNS.
DO NOT TOUCH GLASS UNTIL
COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
!
DANGER
!
AVERTISSEMENT
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this appliance
and shall be installed for the protection of children
and other at-risk individuals.
Une barriére conçu à réduire le risque de brûlures
causées par le verre chaud est fourni avec l’appareil
et sera installé pour la protection des enfants et
d’autres personnes à risque.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is
not convertible for use with other gases, unless a
certifi ed kit is used.
Decorative Product: Not for use as a heating appliance.
OUTDOOR GAS FIREPLACE
$10.00
GSS42CFN
NATURAL GAS MODEL
GSS42CFP
PROPANE GAS MODEL
WARNING: FOR OUTDOOR USE ONLY
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone (705)721-1212 • Fax (705)720-9081 • www.napoleonfireplaces.com • hearth@napoleonproducts.com
Decorative Product: Not for use as heating appliance.
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS, Z21.97 - CSA 2.41.
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE.
INSTALLATION AND
OPERATING INSTRUCTIONS
1.39B
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone (705)721-1212 • Fax (705)722-6031 • www.napoleonfi replaces.com • hearth@napoleonproducts.com
SAFETY INFORMATION
!
WARNING
If the information in these instructions are
not followed exactly, a fi re or explosion
may result causing property damage,
personal injury or loss of life.
- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbour’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the
fi re department.
- Installation and service must be performed by a
qualifi ed installer, service agency or the supplier.
CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS.
$10.00
LA VITRE CHAUDE CAUSERA
DES BRÛLURES.
NE PAS TOUCHER LA VITRE
AVANT QU’ELLE AIT REFROIDI.
NE JAMAIS LAISSER LES
ENFANTS TOUCHER LA VITRE.
HOT GLASS WILL CAUSE
BURNS.
DO NOT TOUCH GLASS UNTIL
COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
!
DANGER
!
AVERTISSEMENT
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this appliance
and shall be installed for the protection of children
and other at-risk individuals.
Une barriére conçu à réduire le risque de brûlures
causées par le verre chaud est fourni avec l’appareil
et sera installé pour la protection des enfants et
d’autres personnes à risque.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is
not convertible for use with other gases, unless a
certifi ed kit is used.
Decorative Product: Not for use as a heating appliance.

Table of Contents

Questions and Answers

  • M
    Mark MooreAug 20, 2025
    What to do if the main burner goes out but the pilot stays on in my Napoleon GSS42CFN Indoor Fireplace?
    • B
      Brittany RossAug 20, 2025
      If the main burner goes out while the pilot light remains on in your Napoleon Indoor Fireplace, there are several possible causes. First, the pilot flame might not be large enough or not engulfing the thermopile; in this case, turn up the pilot flame. Other solutions include cleaning the thermopile connection to the valve, shortening the remote wall switch wire, or replacing a faulty thermostat or switch. It may also be necessary to replace the pilot assembly, thermopile, or valve.
  • J
    jcarrilloAug 22, 2025
    Why won't the pilot light on my Napoleon GSS42CFN Indoor Fireplace stay lit when I release the gas knob?
    • K
      Kathleen DickersonAug 22, 2025
      The gas valve has an inter-lock device which will not allow the pilot burner to be lit until the thermocouple has cooled. Allow approximately 60 seconds for the thermocouple to cool, and then try again.
  • H
    Heather MillerAug 25, 2025
    What to do if there's no gas to the main burner in my Napoleon Indoor Fireplace, even though the pilot is burning and the gas knob/thermostat are on?
    • E
      Eric HallAug 25, 2025
      If your Napoleon Indoor Fireplace has a burning pilot but no gas to the main burner, ensure the system is correctly purged and that you have propane gas. Try turning up the pilot flame. Also, the main burner orifice may be plugged, so remove any blockage. If the issue persists, disconnect the switch wires and connect a jumper wire across terminals 1 & 3; if the main burner lights, check the wires for defects and/or replace wires. In some cases, the valve may be faulty and require replacement.
  • J
    Janet WiseAug 26, 2025
    What should I do if the thermocouple is shorting or faulty in my Napoleon GSS42CFN Indoor Fireplace?
    • R
      robertstrongAug 26, 2025
      If you suspect a shorting or faulty thermocouple in your Napoleon Indoor Fireplace, try loosening and then tightening the thermocouple. Also, clean the thermocouple and valve connection. If these steps don't resolve the issue, you may need to replace the thermocouple or the valve.
  • P
    Peter SantiagoAug 28, 2025
    How to fix carboning that occurs in my Napoleon GSS42CFN Indoor Fireplace?
    • E
      erikhebertAug 28, 2025
      To address carboning in your Napoleon Indoor Fireplace, clean the glass with a recommended gas appliance glass cleaner. Remember: DO NOT CLEAN GLASS WHEN HOT. Regular cleaning prevents permanent marking.
  • S
    Sandra CortezAug 30, 2025
    What to do if the pilot flame is not engulfing the thermocouple in my Napoleon GSS42CFN Indoor Fireplace?
    • C
      Christina PittmanAug 30, 2025
      If the pilot flame isn't engulfing the thermocouple in your Napoleon Indoor Fireplace, gently twist the pilot head to improve the flame pattern around the thermocouple.
  • J
    jesse45Sep 1, 2025
    Why won't the pilot light on my Napoleon GSS42CFN Indoor Fireplace light, and there's no spark at the pilot burner?
    • R
      Rebecca BaxterSep 1, 2025
      If the pilot on your Napoleon Indoor Fireplace won't light and there's no spark, first check if the pilot can be lit by a match. Then, check that the wire is connected to the push button igniter and that the push button igniter is tightened. If the wire insulation is broken or frayed, replace the wire. If the ceramic insulator is cracked or broken, replace the electrode. Also, ensure you have propane gas. The spark gap should be 0.150” (3.8mm) to 0.175” (4.5mm) from the electrode tip and the pilot burner. To ensure proper electrode location, tighten securing nut (finger tight plus 1/4 turn). It may also be necessary to replace the push button ignitor.
  • B
    beckmelindaSep 3, 2025
    What should I do if the flame in my Napoleon GSS42CFN Indoor Fireplace is impinging on the logs or combustion chamber?
    • A
      afieldsSep 3, 2025
      If the flame in your Napoleon Indoor Fireplace is hitting the logs or combustion chamber, verify that the logs are correctly positioned. You can also open the air shutter to increase the primary air. Check the input rate by checking the manifold pressure and orifice size as specified by the rating plate values.
  • K
    kennethsaundersSep 5, 2025
    What causes a white or grey film to form on my Napoleon GSS42CFN Indoor Fireplace?
    • M
      Michael DominguezSep 5, 2025
      The white or grey film that forms is sulphur from fuel being deposited on glass, logs, or combustion chamber surfaces. Check pressure readings to address this issue.
  • J
    James HolmesSep 6, 2025
    What to do if there is no gas at the pilot burner of my Napoleon GSS42CFN?
    • S
      Sophia MathewsSep 6, 2025
      If there's no gas at the pilot burner of your Napoleon Indoor Fireplace, verify that the manual valve is turned on and check the pilot orifice for blockage. If these steps don't work, it might be necessary to replace the valve.

Summary

SAFETY INFORMATION

1.0 INSTALLATION OVERVIEW

3.0 INSTALLATION

3.1 GAS INSTALLATION

Specific steps for connecting the gas supply.

3.2 GAS INLET LOCATIONS

3.3 OPTIONAL WALL SWITCH INSTALLATION

3.4 COMBUSTION AND VENTILATION AIR

Requirements for combustion and ventilation air during installation.

4.0 FRAMING

4.1 CLEARANCE TO COMBUSTIBLES

Minimum clearances required between the appliance and combustible materials.

4.2 MINIMUM ENCLOSURE CLEARANCES

Specifies minimum clearance requirements for the enclosure.

4.3 MINIMUM MANTEL CLEARANCES

Clearances required for installing a mantel above the appliance.

5.0 FINISHING

5.1 LOG PLACEMENT

Detailed instructions for correctly positioning the logs.

7.0 OPERATION

8.0 ADJUSTMENT

8.1 VENTURI ADJUSTMENT

Adjusting the venturi for optimal flame characteristics.

8.2 FLAME CHARACTERISTICS

9.0 MAINTENANCE

12.0 TROUBLESHOOTING

Napoleon GSS42CFN Specifications

General IconGeneral
BrandNapoleon
ModelGSS42CFN
CategoryIndoor Fireplace
LanguageEnglish

Related product manuals