RefertoFigure43withthefollowinginstructions
BOILERS EQUIPPED WITH ELECTRIC IGNITION AND DUAL GAS VALVE
LIGHTING INSTRUCTIONS
NOTE:CHECKWATERLINEOF STEAMBOILER,ORBECERTAINSYSTEMIS FULL
FORWATERBOILER,BEFOREPROCEEDINGWITHTHESEINSTRUCTIONS.
FOR YOUR SAFETY READ BEFORE LIGHTING
WARNING: If you do not follow these instructions exactly, a fire or explosion may result
causing property damage, personal injury, or loss of life.
A. This appliance is equipped with both a secondary pilot which
must be lightedby hand, and an ignition devicewhich automat-
ically lights the main pilot. Light only the secondary pilot by
handfollowingthese instructionsexactly.
B. BEFOREOPERATINGsmell all around the appliance area for
gas. Be sure to smell next to the floor because some gas is
heavierthan air and will settle on the floor.
WHATTO DO IFYOU SMELL GAS
• Do not try to light anyappliance.
• Do not touch any electric switch; do not use any phone in
yourbuilding.
C.
B.
• Immediatelycall your gas supplier from a neighbor'sphone,
Followthe gas supplier'sinstructions.
• If youcannot reachyourgas supplier,call thefire department,
Useonlyyour handto pushin orturn thegas controlknob.
Neverusetools.If the knobwillnotpush in or turnbyhand,
don'ttryto repairit,calla qualifiedservicetechnician.Forceor
attemptedrepairmayresultinafire orexplosion.
Donot usethis applianceif any part has beenunderwater.
Immediatelycall a qualifiedservicetechnicianto inspectthe
applianceandto replaceanypartofthecontrolsystemandany
gascontrolwhichhasbeenunderwater.
LIGHTING INSTRUCTIONS
1.STOP!Readthesafetyinformationaboveonthispage.
2.Setthethermostatto lowestsetting.
3.Turnoffallelectricpowerto theappliance.
4.Ifthe gascontrolassemblyis notvisible,removecontrolaccess
panel.Referto controlassemblyonfollowingpage.
5.If themanualshut-offleverandpilotcockarenotinthe "OFF"
position,turnbothclockwise_-4 to"OFF."
Pil©_ Cock
{ 5how_in "ofF*
Man_al S_tu_- 0ll _osd_on)
Lever (s_o,n ;, -o[r-
6. Wait five (5) minutes to clear out any gas. If you smell gas,
STOP! Follow"B"in the safety informationabove on this page.
Ifyou don'tsmell gas, goto the nextstep.
7.Removethe pilotaccesspanel,if supplied,locatedbelowand
behindthegasvalvedirectlyaboveburnertubes.
8.Findsecondarypilot-- followmetaltubefromgasvalve.Pilotis
betweentwoburnertubes.
R**d Rese+
Svff_,
9.Turnthepilotcockhandlecounterclockwise_ to"ON."
10.Pushin redresetbuttonon pilotvalveall thewayandholdin.
Immediatelylight the pilot witha match.Continueto holdthe
resetbuttonin for aboutone (1) minuteafterthe pilot is lit.
Releasebuttonandit will popbackup.Pilotshouldremainlit.If
itgoesout,repeatsteps5through10.
• If resetbuttondoesnotpopupwhenreleased,stopandimme-
diatelycallyourservicetechnicianor gassupplier.
• Ifthepilotwillnotstaylit afterseveraltries,turnthepilotcock
handleto "OFF"andcallyourservicetechnicianorgas
supplier.
11.Replacepilotaccesspanel,if applicable.
12.Turnrnanualshut-offlevercountercleckwise_ to"ON."
13.Replacecontrolaccesspanel,if applicable.
14.Turnonallelectricpowerto theappliance.
15.Setthermostatto desiredsetting.
16.Iftheappliancewi[Inotoperate,followthe instructions"ToTurn
Off GasToAppliance"andcall yourservicetechnicianor gas
supplier.
TO TURN OFF GAS TO APPLIANCE
1.Set the thermostat to lowest setting.
2. Turnoff all electric powertothe applianceif service isto be per-
formed.
3.If thegascontrolassemblyis notvisible,removecontrolaccess
panel.
4. Turnthe pilotcock and the manual shut-off lever clockwise
to "OFF
5.Replacecontrolaccesspanel,ifapplicable.
27
To Next Page
Loading...
