Perkins 2806C-E18TA - Page 101

F
Fan Drive Bearing - Replace........................... 83
Fault Logging................................................... 34
Features and Controls..................................... 28
Fire Prevention and Explosion Prevention.......11
Ether ............................................................ 13
Fire Extinguisher.......................................... 13
Lines, Tubes, and Hoses ............................. 13
Fluid Recommendations ........................... 45, 47
ELC Cooling System Maintenance.............. 49
Engine Oil .................................................... 46
General Coolant Information ....................... 47
General Lubricant Information..................... 45
Fluid Recommendations (General Fuel
Information) ................................................... 51
Contamination Control Recommendations for
Fuels .......................................................... 58
Diesel Fuel Characteristics.......................... 53
Diesel Fuel Requirements ........................... 52
General Information..................................... 51
Renewable and Alternative Fuels................ 59
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 4
Operation ....................................................... 4
Overhaul ........................................................ 4
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 42
Fuel Conservation Practices ........................... 40
Fuel Related Components in Cold Weather ... 42
Fuel Heaters ................................................ 43
Fuel Tanks ................................................... 42
Fuel System - Prime........................................ 83
2806C Fuel Priming..................................... 83
2806D Fuel Priming..................................... 84
Fuel System Primary Filter (Water
Separator) Element - Replace....................... 84
2806C Primary Filter.................................... 85
2806D Primary Filter.................................... 86
Fuel System Primary Filter/Water
Separator - Drain ........................................... 87
2806C Water Separator Drain ..................... 87
2806D Water Separator Drain ..................... 88
Fuel System Secondary Filter - Replace ........ 88
2806C Secondary Fuel Filter....................... 89
2806D Secondary Fuel Filter....................... 90
Fuel Tank Water and Sediment - Drain ........... 91
Drain the Water and the Sediment .............. 91
Fuel Storage Tanks...................................... 91
Fuel Tank ..................................................... 91
G
General Hazard Information.............................. 7
Containing Fluid Spillage............................... 9
Dispose of Waste Properly .......................... 10
Fluid Penetration ........................................... 9
Inhalation ..................................................... 10
Pressurized Air and Water............................. 8
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ......................... 9
General Information ........................................ 16
Grounding Stud - Inspect/Clean/Tighten......... 91
H
Hoses and Clamps - Inspect/Replace............. 92
Fuel System................................................. 93
Replace the Hoses and the Clamps............ 92
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 24
M
Maintenance Interval Schedule....................... 63
Daily ............................................................. 63
Every 12 000 Service Hours or 6 Years....... 63
Every 2500 Service Hours........................... 63
Every 3000 Service Hours or 2 Years ......... 63
Every 4000 Service Hours........................... 63
Every 500 Service Hours............................. 63
Every 500 Service Hours or 1 Year ............. 63
Every 6000 Service Hours or 3 Years ......... 63
Every 760 000 L (200 770 US gal) of Fuel or
10 000 Service Hours ................................ 63
When Required............................................ 63
Maintenance Log............................................. 98
Maintenance Recommendations .................... 60
Maintenance Records ..................................... 97
Maintenance Section....................................... 45
Manual Stop Procedure .................................. 44
Model View Illustrations .................................. 16
2806C .......................................................... 16
2806D .......................................................... 18
Monitoring System........................................... 28
Action Alert .................................................. 28
SEBU9074-01
101
Index Section