Perkins 2806C-E18TA - Maintenance Interval Schedule

i06769711
Maintenance Interval Schedule
When Required
“ Battery - Recycle” . . . . . . . . . . . . . . . . . . . . . . . . . 64
“ Battery - Replace” . . . . . . . . . . . . . . . . . . . . . . . . . 65
“ Battery or Battery Cable - Disconnect” . . . . . . . . . 66
“ Engine - Clean” . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
“ Engine Air Cleaner Element (Dual Element) -
Inspect/Clean/Replace” . . . . . . . . . . . . . . . . . . . . . . 74
“ Engine Air Cleaner Element (Single Element) -
Inspect/Clean/Replace” . . . . . . . . . . . . . . . . . . . . . . 76
“ Fuel System - Prime”. . . . . . . . . . . . . . . . . . . . . . . 83
“ Fuel Tank Water and Sediment - Drain” . . . . . . . . 91
“ Radiator - Clean” . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Daily
“ Air Tank Moisture and Sediment - Drain” . . . . . . . 64
“ Coolant Level - Check” . . . . . . . . . . . . . . . . . . . . . 71
“ Driven Equipment - Check” . . . . . . . . . . . . . . . . . . 73
“ Engine Air Cleaner Service Indicator - Inspect”. . 77
“ Engine Oil Level - Check” . . . . . . . . . . . . . . . . . . . 78
“ Fuel System Primary Filter/Water Separator -
Drain” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
“ Power Take-Off Clutch - Check” . . . . . . . . . . . . . . 93
“Walk-Around Inspection” . . . . . . . . . . . . . . . . . . . . 94
Every 500 Service Hours
“ Belts - Inspect/Adjust/Replace”. . . . . . . . . . . . . . . 66
“ Engine Air Cleaner Element (Dual Element) -
Inspect/Clean/Replace” . . . . . . . . . . . . . . . . . . . . . . 74
“ Engine Air Cleaner Element (Single Element) -
Inspect/Clean/Replace” . . . . . . . . . . . . . . . . . . . . . . 76
“ Engine Crankcase Breather - Clean” . . . . . . . . . . 77
“ Engine Oil Sample - Obtain” . . . . . . . . . . . . . . . . . 79
“ Engine Oil and Filter - Change”. . . . . . . . . . . . . . . 79
Every 500 Service Hours or 1 Year
“ Battery Electrolyte Level - Check” . . . . . . . . . . . . 65
“ Cooling System Supplemental Coolant Additive
(SCA) - Test/Add” . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
“ Fuel System Primary Filter (Water Separator)
Element - Replace” . . . . . . . . . . . . . . . . . . . . . . . . . 84
“ Fuel System Secondary Filter - Replace”. . . . . . . 88
“Grounding Stud - Inspect/Clean/Tighten” . . . . . . . 91
“ Hoses and Clamps - Inspect/Replace”. . . . . . . . . 92
“ Starting Motor - Inspect” . . . . . . . . . . . . . . . . . . . . 94
“ Water Pump - Inspect”. . . . . . . . . . . . . . . . . . . . . . 95
Every 2500 Service Hours
“ Coolant Temperature Regulator - Replace” . . . . . 71
“ Electronic Unit Injector - Check/Replace” . . . . . . 73
“ Engine Mounts - Inspect” . . . . . . . . . . . . . . . . . . . 78
“ Engine Protective Devices - Check” . . . . . . . . . . . 82
“ Engine Valve Lash - Check” . . . . . . . . . . . . . . . . . 82
“ Engine Valve Rotators - Inspect” . . . . . . . . . . . . . 82
Every 3000 Service Hours or 2
Years
“ Coolant (DEAC) - Change” . . . . . . . . . . . . . . . . . . 68
Every 4000 Service Hours
“ Air Compressor - Check”. . . . . . . . . . . . . . . . . . . . 64
Every 6000 Service Hours or 3
Years
“ Coolant Extender (ELC) - Add” . . . . . . . . . . . . . . . 71
Every 760 000 L (200 770 US gal) of
Fuel or 10 000 Service Hours
“ Fan Drive Bearing - Replace” . . . . . . . . . . . . . . . . 83
“ Overhaul Considerations” . . . . . . . . . . . . . . . . . . . 93
Every 12 000 Service Hours or 6
Years
“ Coolant (ELC) - Change”. . . . . . . . . . . . . . . . . . . . 69
SEBU9074-01
63
Maintenance Section
Maintenance Interval Schedule