Perkins M92B - Page 6

Contents N37347
How to check the specic gravity of the coolant .....................................................23
How to drain the raw water system ...........................................................................24
How to check the impeller of the raw water pump ................................................... 25
How to check the drive belt ........................................................................................26
How to adjust the belt tension ........................................................................26
How to renew the element of the fuel lter ...............................................................27
Fuel pre-lter ....................................................................................................27
Atomiser maintenance ................................................................................................28
Atomiser faults .................................................................................................28
How to remove and to t an atomiser .......................................................................29
How to remove ..................................................................................................29
How to t ......................................................................................................................30
How to eliminate air from the fuel system ................................................................31
How to renew the lubricating oil ................................................................................32
How to renew the canister of the lubricating oil lter ..............................................33
How to renew the lubricating oil of the Newage PRM 500D reverse gearbox .......34
How to renew the lubricating oil of the ZF 45 A reverse gearbox ...........................35
Air lter .........................................................................................................................36
Restriction indicator ....................................................................................................37
How to check the valve tip clearances ...................................................................... 38
Seacock strainer ..........................................................................................................39
Corrosion .....................................................................................................................39
Supplementary tools ...................................................................................................39
Power take-off ..............................................................................................................39
5 Engine uids ............................................................................................41
Fuel specication ........................................................................................................41
Lubricating oil specication .......................................................................................42
Coolant specication ..................................................................................................43
6 Fault diagnosis ........................................................................................45
Problems and possible causes .................................................................................. 45
List of possible causes ...............................................................................................46
7 Engine preservation ................................................................................49
Introduction ..................................................................................................................49
Procedure .....................................................................................................................49
How to add antifreeze to the raw water system for engine
preservation purposes ................................................................................................50
8 Parts and service .....................................................................................51
Introduction ..................................................................................................................51
Service literature .........................................................................................................51
Training .........................................................................................................................51
On-board spares kit.....................................................................................................51